Subaru Outback XT since 2019, repair e-manual

Content

General description

• Foreword
• Specifications
• Precaution
• Repair contents
• Identification
• Recommended materials
• Pre-delivery inspection
• Periodic maintenance services

Fuel injection

• General description
• Throttle body
• Intake manifold
• Tumble generator valve
• Tumble generator valve actuator
• Fuel insulator
• Fuel injector
• Fuel pressure sensor
• High pressure fuel pump
• High pressure fuel delivery pipe
• Engine wiring harness
• Engine coolant temperature sensor
• Engine oil temperature sensor
• Crankshaft position sensor
• Crankshaft position sensor plate
• Camshaft position sensor
• Oil control solenoid
• Knock sensor
• Throttle position sensor
• Mass air flow and intake air temperature sensor
• Manifold absolute pressure sensor
• Front oxygen (a/f) sensor
• Rear oxygen sensor
• Si-drive (subaru intelligent drive) selector
• Engine control module (ECM)
• Main relay
• Fuel pump relay
• Fuel
• Fuel tank protector
• Fuel tank
• Fuel filler pipe
• Fuel pump
• Fuel level sensor
• Fuel sub level sensor
• Fuel filter
• Fuel delivery and evaporation lines
• Symptoms and causes

Emission control

• General description
• Front catalytic converter
• Rear catalytic converter
• Canister
• Purge control solenoid valve
• EGR control valve
• EGR pipe
• EGR cooler
• Fuel level sensor
• Fuel sub level sensor
• Drain filter
• Leak check valve
• PCV connector
• PCV hose
• PCV valve

Intake

• General description
• Air cleaner element
• Air intake duct
• Air cleaner case
• Air intake boot

Mechanical

• General description
• Compression
• Idle speed
• Ignition timing
• Intake manifold vacuum
• Engine oil pressure
• Fuel pressure
• Cam clearance
• Engine
• Engine mounting
• Preparation for overhaul
• Vacuum pump
• V-belt
• Crank pulley
• Chain cover
• Timing chain
• Cam sprocket
• Crank sprocket
• Rocker cover
• Camshaft
• Cam carrier
• Cylinder head
• Cylinder block
• Intake and exhaust valve
• Piston
• Connecting rod
• Crankshaft
• Symptoms and causes
• Engine noise

Exhaust

• General description
• Front exhaust pipe
• Rear exhaust pipe
• Muffler

Cooling

• General description
• Radiator fan system
• Engine coolant
• Water pump
• Thermo control valve
• Water pipe
• Thermostat
• Radiator
• Radiator cap
• Radiator fan and fan motor
• Reservoir tank
• Radiator fan relay
• Active grille shutter
• Symptoms and causes

Lubrication

• General description
• Oil pressure system
• Engine oil
• Oil filter
• Oil pump
• Oil pan
• Oil pressure switch
• Oil pipe
• Oil level switch
• Symptoms and causes

Speed control systems

Ignition

• General description
• Spark plug
• Ignition coil

Starting / charging systems

• General description
• Charging system
• Starter
• Starter relay
• Generator
• Battery
• Battery cable
• Battery sensor
• Auto start stop DC/DC converter

Body and electrical

• Blind spot detection-rear cross traffic alert
• Body control-communication system
• Body structure
• Entertainment and monitoring
• Exterior body panels
• Exterior-interior trim
• EyeSight
• Glass-windows-mirrors
• Horn
• Instrumentation and driver info
• Lighting system
• Power rear gate system
• Reverse automatic braking
• Seats
• Security and locks
• Sunroof
• Wiper and washer systems

Vehicle dynamics control (VDC)

• General description
• Relay and fuse
• Vehicle dynamics control system
• VDC control module and hydraulic control unit
• ABS sequence control
• VDC sequence control
• Brake lamp relay
• Yaw rate and G sensor
• Steering angle sensor
• Front abs wheel speed sensor
• Rear ABS wheel speed sensor
• Front magnetic encoder
• Rear magnetic encoder
• General diagnostic table

Brake

• General description
• Front brake pad
• Front disc rotor
• Front disc brake
• Rear brake pad
• Rear disc rotor
• Rear disc brake
• Master cylinder
• Brake booster
• Brake fluid
• Air bleeding
• Brake hose
• Brake pipe
• Brake pedal
• Stop light switch
• Brake vacuum pump
• General diagnostic table

Parking brake

• Parking brake system
• Relay and fuse
• Parking brake
• Parking brake actuator
• Parking brake switch
• Emergency release of electronic parking brake
• General diagnostic table

Driveline and axle

• Differentials
• Propeller shaft - drive shaft - axle

Steering

• General description
• Relay and fuse
• Power steering system
• Steering wheel
• Steering heater system
• Universal joint
• Steering column
• Electric power steering gearbox
• Power steering control module
• General diagnostic table

Suspension

• Front suspension
• Rear suspension
• Wheel and tire system

Control systems

• General description
• Shift lock control system
• Select lever
• Select cable
• Shift lock solenoid and P range switch
• Symptoms and causes

Continuously variable transmission

• General description
• CVTF
• Differential gear oil
• AWD on/off switching mode
• Road test
• Stall test
• Time lag test
• Line pressure test
• Secondary pressure test
• Transfer clutch pressure test
• Transmission
• Transmission mounting system
• Extension case oil seal
• Differential side retainer oil seal
• Inhibitor switch
• Turbine speed sensor
• Secondary speed sensor
• Primary speed sensor
• Line pressure sensor
• Secondary pressure sensor
• Oil pan
• Control valve body
• Electric fluid pump
• Transmission harness
• Transmission control module (TCM)
• Relay and fuse
• CVTF cooler (with warmer function)
• CVTF cooler pipe and hose
• CVTF cooler (air cooling)
• Air breather hose
• Drive plate
• Torque converter
• Preparation for overhaul
• At learning
• Symptoms and causes

Heater / airconditioner / ventilator

Airbag system and seat belt system

Wiring diagrams

• How to read wiring diagrams
• List of signal name
• Harness repair kit
• Fuse and relay
• Power supply circuit
• Ground circuit
• Active grille shutter
• Airbag system
• Air conditioning system
• Audio and navigation system
• Auto start stop
• Back-up light system
• Blind spot detection/rear cross traffic alert
• Can communication system
• Charging system
• Clearance light and illumination light system
• Combination meter system
• CVT control system
• Daytime running light system
• Door lock control system
• Driver monitoring system
• Electric power steering system
• Engine electrical system
• Eyesight system
• Front accessory power supply socket system
• Front fog light system
• Front view monitor
• Front wiper and washer system
• Headlight beam leveler system
• Headlight system
• Horn system
• Immobilizer system
• Interior light system
• Keyless access with push button start system
• Keyless entry system
• Mirror heater system
• Occupant detection system
• OP connector system
• Parking brake / brake fluid level warning light system
• Power rear gate system
• Power seat system
• Power window system
• Radiator fan system
• Rear accessory power supply socket system
• Rear defogger system
• Rearview camera system
• Rearview mirror system
• Rear wiper and washer system
• Remote control mirror system
• Remote engine start system
• Reverse automatic braking
• Seat belt warning system
• Seat heater system
• Seat ventilation system
• Security system
• Shift lock control system
• Starter system
• Steering heater system
• Stop light system
• Sunroof control system
• Telematics system
• Tire pressure monitoring system
• Trailer hitch connector system
• Turn signal light and hazard light system
• Vehicle dynamics control system
• Wiper deicer system
• Harness components location
• Front wiring harness
• Bulkhead wiring harness
• Engine wiring harness and transmission cord
• Steering wheel cord
• Roof cord
• Rear wiring harness
• Front seat wiring harness
• Door cord
• Rear wiring harness and trunk lid cord
• Rear wiring harness and rear gate cord
• Antenna cord

Diagnostic manual

Customers reviews