Foton View Series since 2006, maintenance e-manual

Content

Introduction

• How to use this manual
• Identification information
• Repair instruction
• How to troubleshoot
• Terms

Preparation

Service specifications

Diagnostics

Engine control system

• Gasoline engine control system
• Engine control module
• Engine coolant temperature sensor
• Throttle body
• Idle air control motor
• Throttle position sensor
• Manifold absolute pressure/intake temperature sensor
• Upstream oxygen sensor
• Downstream oxygen sensor
• Canister solenoid valve
• Vehicle speed sensor
• Ignition control module

Fuel

• Fuel system
• Fuel tank
• Fuel filter
• Fuel pump
• Fuel injector
• Fuel filling door

Emission control

• Fuel tank cap
• Charcoal canister
• Charcoal canister solenoid valve
• Positive crankcase ventilation valve

Intake air

• Intake air system
• Intake air hose
• Air filter
• Air straining box
• Intake manifold
• Throttle body

Engine mechanical

• Engine mechanical part
• Engine assy
• Engine timing chain cover
• Engine timing chain
• Rocker arm / rocker shaft
• Hydraulic adjuster / valve push rod
• Camshaft
• Cylinder head
• Valve/valve spring
• Piston and connecting rods
• Crankshaft/engine block / flywheel

Exhaust

• Exhaust pipe
• Exhaust manifold

Cooling

• Cooling system
• Coolant
• Radiator
• Silicone oil fan and fan cowl
• Thermostat
• Coolant pump

Lubrication

• Lubrication system
• Engine
• Oil filter
• Oil pan
• Oil pump

Ignition

• Ignition coil / spark plug wire / spark plug

Starting and charging

• Starting and charging system
• Generator
• Starter
• Battery

Front suspension

• Front wheel alignment
• Front shock absorber
• Torsion bar spring
• Upper control arm
• Lower control arm
• Stabilizer bar
• Strut rod

Rear suspension

• Rear shock absorber
• Rear leaf spring

Tire and wheel

Axle and propeller shaft

• Propeller shaft
• U-joint
• Center support bearing
• Axle hub and steering knuckle
• Axle hub
• Steering knuckle
• Rear axle
• Final drive oil
• Axle shaft
• Rear axle housing welding
• Differential
• Drive pinion

Brake

• Brake fluid
• Brake pedal
• Brake master cylinder
• Brake vacuum booster
• Front brake
• Rear brake
• Load sensing proportioning and by- pass valve
• Hydraulic pressure regulator
• Vehicle speed sensor

Parking brake

• Parking brake operation handle
• Brake actuator lever sub

Transmission

• Output shaft
• Counter shaft and reverse idler gear shaft
• Input shaft

Clutch

• Clutch fluid
• Clutch pedal
• Clutch master cylinder
• Clutch slave cylinder
• Clutch sub

Steering column

• Steering wheel
• Combination switch
• Steering column
• Steering propeller shaft

Power steering

• Steering fluid
• Power steering fluid reservior
• Power steering pump
• Power steering line
• Steering box

Heater and air conditioning

• Vent duct
• Heater pipe
• Front heater
• Refrigerant
• Compressor oil
• Front evaporator
• Rear evaporator
• Compressor
• Front blower
• Condenser
• Reciever tank

Seat belt

• Driver / assistant driver seat belt
• Passenger seat belt
• Buckle
• Retractor

Lighting

• Front combination lamp
• Front fog lamp
• Rear combination lamp
• Licence lamp
• Front dome light
• Rear dome light
• Combination switch
• Fog lamp switch
• Rear dome light switch

Wiper and washer

Audio system

• Radio
• Front speaker
• Radio antenna

Wiring

• Power source
• Engine control system
• Starting system
• Charging system
• Brake control system
• Heater and air conditioning control system
• Light system
• Wiper and washer
• Radio
• Power socket
• Communication system
• Power mirror
• Rear window defroster
• Instrument cluster
• Power door lock system
• Power window control
• Connector views

Communication system

Windshield

Instrument panel

• Dashboard
• Instrument cluster

Seat

• Driver / assistant driver seat
• Passenger seat

Door locks

Doors

Exterior and interior trim

• Front grille
• Front bumper
• Wheel fender
• Rear bumper
• Sun visor
• Step board
• Vehicle door inner guard board
• Side wall guard board
• Floor decorative parts
• Roof panel

Vehicle control system

• Ignition switch

Index

Customers reviews