Our books can be purchased by cards єPidtrimka!

Content

Your car Toyota Corolla

  • Introduction
  • Safety first!
  • Troubleshooting an emergency
  • If the engine does not start and the starter motor does not scroll
  • If the engine does not start and the starter motor rotates normally
  • Starting the engine from an additional power source
  • Wheel replacement
  • Leak detection
  • Towing
  • Weekly checks
  • Checks under the hood of the car
  • Engine oil level
  • Coolant level
  • Brake fluid level
  • Washer fluid level
  • Tire condition and air pressure
  • Windshield wipers
  • Battery
  • Electrical systems
  • Working fluids and lubricants
  • Tire pressure

Instruction manual

  • General view of the dashboard
  • Signal indicators on the dashboard
  • General view of the instrument panel
  • Sensors and pointers
  • Operation of instruments and controls
  • Fuses

Regular maintenance - petrol engines

  • General information
  • Regular maintenance
  • Replacement of engine oil and filter
  • Checking hoses and leaks of working fluids
  • Checking the drive shaft anther
  • Lubrication of awnings and locks
  • Replacement and check of a level of a working liquid of an automatic transmission
  • Checking and replacing the auxiliary drive belt
  • Replacement and inspection of the air filter
  • Checking and adjusting the parking brake
  • Checking brake pads
  • Checking the suspension and exhaust system
  • Checking the steering and suspension system
  • Checking and adjusting the clutch pedal
  • Checking the particle filter
  • Road test
  • Checking the parking brake pads
  • Replacing the batteries of the control panel
  • Brake fluid replacement
  • Replacing coolant
  • Replacement and check of oils level
  • Replacement of spark plugs
  • Checking and adjusting the valve clearance

Regular maintenance - diesel engines

  • General information
  • Regular maintenance
  • Replacement of engine oil and filter
  • Checking hoses and leaks of working fluids
  • Checking the drive shaft anther
  • Lubrication of awnings and locks
  • Replacement and check of oils level
  • Checking and replacing the auxiliary drive belt
  • Replacement and inspection of the air filter
  • Checking and adjusting the parking brake
  • Checking brake pads
  • Check of suspensions and pipelines of system of release of the fulfilled gases
  • Checking the steering and suspension system
  • Checking and adjusting the clutch pedal
  • Checking the particle filter
  • Road test
  • Replacing the fuel filter
  • Checking the parking brake pads
  • Replacing the batteries of the control panel
  • Brake fluid replacement
  • Replacing coolant
  • Checking and replacing the hose and valve of the crankcase ventilation system
  • Checking and adjusting the valve clearance
  • Replacing the timing belt

Repair procedures without removing the engine from the engine compartment - gasoline engines

  • General information
  • Compression check
  • The top dead center of the piston of the first cylinder
  • Cylinder head cover - removal and installation
  • Chain of timing and sprocket drive -replacement, inspection and installation
  • Variable timing components (VVT-i) - removal, inspection and installation
  • Right crankshaft oil seal - replacement
  • Camshafts and pushers - removal, inspection and installation
  • Cylinder head - removal and installation
  • Oil pan - removal and installation
  • Oil pump - removal, inspection and installation
  • Engine oil pressure sensor - replacement
  • Flywheel - removal, inspection and installation
  • Crankshaft oil seal - replacement
  • Engine / gearbox mountings - check and replace

Repair procedures without removing the engine from the engine compartment - diesel engines

  • General information
  • Procedures that can be performed without removing the engine from the engine compartment
  • The top dead center of the piston of the first cylinder
  • Cylinder head cover - removal and installation
  • Intake manifold - removal and installation
  • Exhaust manifold - removal and installation
  • Timing belt and sprockets - removal, inspection and installation
  • Right crankshaft oil seal - replacement
  • Right camshaft seal - replacement
  • Camshafts and pushers - removal and installation
  • Cylinder head - removal and installation
  • Oil pan - removal and installation
  • The upper shell of the oil pump and the pallet - removal, inspection and installation
  • Flywheel - removal and installation
  • Crankshaft oil seal - replacement
  • Engine supports - checking and replacing

Removing the engine from the engine compartment and the overhaul procedure

  • General information
  • Major engine repairs - general information
  • Engine removal - methods and precautions
  • Engine - removal and installation
  • Alternative engine replacement
  • Engine overhauling - sequence of disassembly
  • Cylinder head - disassembly
  • Cylinder head and valves - cleaning and checking
  • Valves - maintenance
  • Cylinder head - assembly
  • Piston / connecting rod assembly - removal
  • Crankshaft removal
  • Cylinder block - cleaning
  • Cylinder block - check
  • Piston / connecting rod assembly - check
  • Crankshaft check
  • The main bearing and the lower end of the connecting rod - check
  • Engine overhaul - assembly sequence
  • Piston rings - installation
  • Crankshaft - installation
  • Pistons / connecting rods - installation
  • The engine is the beginning of traffic after major repairs

Cooling system, heater and air conditioning

  • General information
  • Coolant / antifreeze - general information
  • Thermostat - check and replace
  • Engine cooling fan and relay - check and replace
  • Radiator - removal and installation
  • Water pump - check
  • Water pump - removal and installation
  • Coolant temperature transmitter - check and replace
  • Motor fan resistor and fan motor - replacement
  • Heatsink radiator - removal and installation
  • Control unit for air conditioning and heater - removal and installation
  • Air conditioning and heating system - check and maintenance
  • Receiver / dehumidifier of air conditioning system - removing and installing
  • Air conditioning compressor - removal and installation
  • Air conditioning condenser - removing and installing
  • Evaporator of air conditioning system - removal and installation
  • Air conditioning sensors - replacement

Power system and exhaust system - gasoline engines

  • General information
  • Fuel injection system - pressure relief
  • Fuel pump - removal and installation
  • Fuel level transmitter - check and replace
  • Fuel lines and fittings - check and replace
  • Fuel tank - removal and installation
  • Fuel tank cleaning and repair - general information
  • Air filter assembly - removing and installing
  • Throttle cable - removal, installation and adjustment
  • Fuel injection system - general information
  • Fuel injection system - check and adjustment
  • Fuel injection system - component testing and replacement
  • Intake manifold - removal and installation
  • Exhaust manifold - removal and installation
  • Exhaust system - removal and installation

Power system and exhaust system - diesel engines

  • General information
  • Fuel lines and fittings - general information
  • Fuel level transmitter - removing and installing
  • Fuel tank - removal and installation
  • Cleaning and repair of the fuel tank
  • Air filter and intake system - removing and installing
  • Fuel filter - removal, replacement and installation
  • High-pressure fuel pump (injection pump) - check, removal and installation
  • Common rail system for high pressure - removal and installation
  • High pressure fuel lines - removal and installation
  • Nozzles - check, remove and install
  • On-board diagnostic system and DTCs
  • Electrical components of the fuel injection system - check, remove and install
  • Turbocharger - check, removal and installation
  • Intercooler - removing and installing
  • Exhaust system - removal and installation

Control systems for harmful emissions - gasoline engines

  • General information
  • Fuel vapor recovery system (EVAP)
  • System of forced ventilation of crankcase (PCV)
  • Catalytic converter

Emission control systems - diesel engines

  • General information
  • Crankcase ventilation system - general information
  • Exhaust gas recirculation system - checking, removing and installing

Starting and recharging systems

  • General information
  • Battery - check and charge
  • Battery - removal and installation
  • Recharging system - general information and precautions
  • Charge system - check
  • Generator - removal and installation
  • Alternator regulator / brush holder - replacement
  • Generator - check and overhaul
  • Start-up system - general information and precautions
  • Starter - check in the car
  • Starter - removal and installation
  • Glow plug system (diesel engines) - general information
  • Glow plugs (diesel engines) - check and replace

Ignition system - petrol engines

  • General information
  • Ignition coil - replacement
  • Detonation sensor - removal, inspection and installation

Clutch

  • General information
  • Hydraulic clutch system - bleeding pressure
  • Clutch components - removal, inspection and installation
  • Clutch release bearing and lever - removal, inspection and replacement
  • Clutch master cylinder - removal, overhaul and installation
  • Clutch slave cylinder - removal, overhaul and installation
  • Clutch pedal position sensor - check and replace

Manual transmission

  • General information
  • Gear shift cables - removing and installing
  • Gear lever - removal and installation
  • Back-up light switch - check and replace
  • Manual gearbox - removing and installing
  • Major overhaul of a manual transmission - general information
  • Oil seals - replacement

Automatic transmission

  • General information
  • Diagnostics - general information
  • Replacing the gland
  • Switching cable - removal, installation and adjustment
  • System for locking the selector lever in P or N mode - removal, installation and adjustment
  • Transmission supports - check and replace
  • Automatic gearbox - removal and installation

Power shafts

  • Drive shafts - general information
  • Drive shafts - removal and installation
  • Replacement of an anther of a power shaft and Shrus check

Brake system

  • General information
  • Hydraulic system - air removal
  • Hydraulic connections and hoses
  • Front brake pads are replacement
  • Rear brake pads - replacement
  • Front disc brake - checking, removing and installing
  • Rear disc brake - removal, inspection and installation
  • Front brake caliper - removal, overhaul and installation
  • Rear brake caliper - removal, overhaul and installation
  • Brake shoes - replacement
  • Master brake cylinder - removal, overhaul and installation
  • Brake pedal - removal and installation
  • Vacuum brake booster - checking, removing and installing
  • The check valve of the vacuum amplifier of brakes - removal, check and installation
  • Parking brake - adjustment
  • Parking brake lever - removal and installation
  • Parking brake cables - removal and installation
  • Brake light switch - removal, installation and adjustment
  • Vacuum pump (diesel engines) - check, removal and installation
  • Anti-lock braking system (ABS) - general information
  • Anti-lock components (ABS) - removal and installation

Steering and suspension

  • General information
  • The front suspension bracket assembly - removal, inspection and installation
  • Rack / spring assembly - replacement
  • Stabilizers of lateral stability and the plug (forward) - removal and installation
  • Suspension lever - removal, inspection and installation
  • Ball bearings - replacement
  • Hub carrier and hub assembly (front) - removal and installation
  • Hub and bearing assembly (front) - removing and installing
  • Stabilizer of transverse stability (rear) - removal and installation
  • Rear suspension bracket assembly - removal, inspection and installation
  • Stabilizer bar for lateral stability - removal and installation
  • Bearing and hub assembly (rear) - removal and installation
  • Rear axle - removal and installation
  • Steering system - general information
  • Steering wheel - removal and installation
  • The ends of the tie rod - removal and installation
  • Anthers of the steering rack - replacement
  • Steering rail - removal and installation
  • Steering column and servo - removal and installation
  • Wheels and tires - general information
  • Wheel alignment - general information

Body structure and components

  • General information
  • Maintenance - body and frame
  • Maintenance - upholstery and rugs
  • Elimination of minor body damage - repairs
  • Elimination of serious damage to the body - repair
  • Front bumper - removal and installation
  • Rear bumper - removal and installation
  • Hood - removal, installation and adjustment
  • A cable of blocking and opening of a cowl - removal and installation
  • Hood lock - removal and installation
  • Radiator grille - removal and installation
  • Door - removal, installation and adjustment
  • Internal door trim panel - Removing and installing
  • Door handle and lock components - removal and installation
  • Door window and window lift - removal and installation
  • Luggage compartment lid and lock components - removal and installation
  • The luggage compartment door, the components of the lock and the support pillars - removal and installation
  • Components of the central lock - removal and installation
  • Components of electric glass lifts - removal and installation
  • Mirrors and their components - removal and installation
  • Windscreen, fixed glass, rear window / tailgate window - general information
  • Hatch - general information and servo replacement
  • External components of the body - removal and installation
  • Seats - removal and installation
  • Seat belt pretensioner mechanism - general information
  • Components of seat belts - removal and installation
  • Internal lining - removal and installation
  • Central console - removal and installation
  • Complete trim panels - removal and installation

Electrical equipment and electrical systems

  • General information
  • Detection of malfunctions in the electrical system - general information
  • Fuses and relays - general information
  • Switches - removal and installation
  • Dashboard - removal and installation
  • The control unit of direction indicators / light alarm - replacement
  • Lamps (external lighting) - replacement
  • Lamps (interior lighting) - replacement
  • External headlamps - removal and installation
  • Headlamps height - check and adjustment
  • Servo drive for headlights - removal and installation
  • Acoustic signal - replacement
  • Washer system components - removal and installation
  • Wiper arm - removal and installation
  • Servo and windshield wiper retractor - removing and installing
  • Rear window wiper motor - removing and installing
  • Audio system - removal and installation
  • Speakers - removal and installation
  • Passive safety system - general information and precautions
  • Airbag system - component replacement
  • Electrical diagrams - general information

Applications

  • Overall dimensions and weight
  • Fuel consumption
  • Vehicle identification numbers
  • General repair procedures
  • Lifting the car with a jack and the point of the pillars
  • Tools and devices
  • Technical condition check
  • Troubleshooting
  • Glossary
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
(10)

The top dead center of the piston of the first cylinder of Toyota Corolla since 2001

Typically, users of our site find this page for the following queries:
will not start Toyota Corolla, engine Toyota Corolla, repair Toyota Corolla, engine repair Toyota Corolla, characteristics Toyota Corolla, valve adjustment Toyota Corolla, intake system Toyota Corolla, exhaust system Toyota Corolla, power system Toyota Corolla

Sorry, the article is only available in Russian.

To read the article, you need to change the language on the site.