Toyota Tacoma 2005 thru 2008, repair e-manual

Content

Introduction

Preparation

Maintenance

Service specifications

Engine mechanical

• Drive belt
• Valve clearance
• Timing chain
• Camshaft
• Cylinder head
• Engine front oil seal
• Engine
• Engine unit

Engine control system

• SFI system
• Camshaft timing oil control valve
• Crankshaft position sensor
• Engine coolant temperature sensor
• Throttle body
• Knock sensor
• Efi relay
• Circuit opening relay
• ECM
• Accelerator pedal

Fuel system

• Fuel injector
• Fuel pressure regulator
• Fuel pump
• Fuel pump resistor
• Fuel tank

Emission control emission control system

• Canister
• Ventilation valve
• Duty vacuum switching valve
• Air fuel ratio sensor
• Heated oxygen sensor
• Fuel tank cap

Intake system

Exhaust

• Exhaust pipe

Cooling system

• Coolant
• Water pump
• Thermostat
• Fan
• Radiator

Lubrication system

• Oil filter
• Oil pump
• Engine oil cooler

Ignition

• Ignition coil
• VVT sensor

Starting system

• Starter
• Starter relay
• Ignition switch

Charging system

• Generator

Automatic transmission system

• Speed sensor
• Transmission wire
• ATF temperature sensor
• Park / neutral position switch
• Valve body assembly
• Shift lock system
• Floor shift

Clutch

• Clutch pedal
• Clutch master cylinder
• Clutch release cylinder
• Clutch accumulator
• Clutch unit
• Clutch start cancel switch

Manual transmission system

• Manual transmission extension housing oil seal
• Manual transmission unit
• Input shaft
• Output shaft
• Counter gear and reverse idler gear
• Transfer adaptor oil seal

Transfer system

• Transfer oil
• Extension housing oil seal
• Touch select 2-4 and high-low system

Propeller shaft

• Front propeller shaft
• Rear propeller shaft

Drive shaft

• Front drive shaft
• Rear drive shaft

Differential

• Differential lock system
• Rear differential carrier
• Front differential carrier
• Differential side gear shaft oil seal
• Rear differential carrier oil seal
• Differential oil
• Axle
• Front axle hub bolt
• Front axle hub
• Rear axle hub bolt
• Rear axle shaft

Suspension

• Front wheel alignment
• Front shock absorber with coil spring
• Front upper suspension arm
• Front lower suspension arm
• Front stabilizer bar
• Rear leaf spring
• Rear shock absorber
• Rear stabilizer bar

Tire and wheel

• Tire pressure warning system
• Tire pressure warning receiver
• Tire pressure warning valve and transmitter
• Tire pressure warning ecu

Brake control

• Anti-lock brake system
• Vehicle stability control system
• Deceleration sensor
• Yaw rate and deceleration sensor
• Steering angle sensor

Brake

• Brake fluid
• Brake pedal
• Brake master cylinder
• Brake booster
• Hydraulic brake booster
• Front brake
• Rear brake
• Parking brake system
• Parking brake lever

Parking brake

• Parking brake lever
• Parking brake cable

Steering column

• Steering system
• Steering column
• Power steering system
• Vane pump
• Power steering link

Air conditioning

• Refrigerant
• Air conditioning unit
• Blower motor
• Compressor and magnetic clutch
• Condenser
• Servo motor
• Evaporator temperature sensor
• Magnetic clutch relay
• Heater relay
• Air conditioning amplifier

Supplemental restraint system

• Airbag system
• Occupant classification system
• Spiral cable
• Front passenger airbag
• Curtain shield airbag
• Front seat side airbag
• Center airbag sensor
• Front airbag sensor
• Side airbag sensor
• Rear airbag sensor
• Seat position sensor
• Front seat cushion
• Occupant classification ECU
• Airbag cut-off switch

Seat belt

• Front seat inner belt
• Front seat outer belt
• Front center seat outer belt
• Rear seat inner belt
• Rear seat outer belt
• Rear center seat outer belt

Engine immobiliser

Cruise control

• Cruise control main switch Clutch switch

Lighting

• Headlight
• Fog light
• Rear combination light
• License plate light
• High mounted stop light
• Room light
• Headlight dimmer switch
• Front fog light switch
• Stop light switch
• Front door courtesy switch
• Rear door courtesy switch
• Turn signal flasher
• Headlight relay
• Headlight dimmer relay
• Taillight relay
• Fog light relay
• Trailer socket
• Towing tail relay
• Towing converter relay

Wiper and washer

• Front wiper motor
• Wiper switch
• Washer nozzle

Door lock

• Power door lock control system
• Wireless door lock control system
• Key reminder warning system

Meter

Audio / visual

Horn

Windshield / windowglass

• Power window control system
• Windshield glass
• Back window glass

Mirror

Instrument panel

Exterior

• Bumper
• Name plate
• Door belt moulding
• Tail gate protector
• Fender panel mudguard

Interior

• Floor footrest
• Roof headlining

Can communication

Customers reviews