Toyota Celica since 2005, repair e-manual

Content

Introduction

• How to use this manual
• Identification information
• Repair instructions
• For all vehicles
• How to troubleshoot ecu controlled systems
• Terms

Maintenance

• Outside vehicle
• Inside vehicle
• Under hood
• Engine
• Brake
• Chassis

Preparation

Service specification

Diagnostics

Engine mechanical

• CO/CH
• Compression
• Valve clearance
• Ignition timing
• Idle speed
• Cylinder head
• Timing chain
• Engine unit
• Cylinder block
• Exhaust system

Emission control

• Emission control system
• Parts layout and schematic drawing
• Positive crankcase ventilation system
• Evaporative emission control
• Three-way catalytic converter system
• Secondary air injection system

SFI

• SFI system
• Fuel pump
• Fuel pressure regulator
• Injector
• Fuel tank and line
• Mass air flow meter
• Throttle body
• Idle air control valve
• Camshaft timing oil control valve
• EFI main relay
• Circuit opening relay
• VSV for intake air control valve
• VSV for evaporative emission
• VSV for canister closed valve
• VSV for pressure switching valve
• Engine coolant temperature sensor
• Vapor pressure sensor
• Knock sensor
• Heated oxygen sensor
• Accelerator pedal position sensor
• Engine control module
• Fuel cut RPM

Cooling

• Coolant
• Water pump
• Thermostat
• Radiator
• Electric cooling fan
• Cooling fan relay

Lubrication

• Oil and filter
• Oil pump
• Oil nozzle

Ignition

• Ignition system
• Ignition coil
• Camshaft position sensor
• Crankshaft position sensor

Starting

• Starting system
• Starter
• Starter relay

Charging

• Charging system
• Generator

Clutch

• Troubleshooting
• Clutch pedal
• Clutch master cylinder
• Clutch release cylinder
• Clutch unit

Manual transaxle

• Troubleshooting
• Manual transaxle unit
• Manual transaxle assembly
• Input shaft
• Output shaft
• Shift and select lever shaft
• Differential case
• Shift lever and control cable

Automatic transaxle

• Automatic transaxle system
• Vehicle speed sensor
• Speed sensor
• ATF temperature sensor
• Park/neutral position switch
• Valve body assembly
• Differential oil seal
• Shift lock system
• Floor shift assembly
• Automatic transaxle unit
• Torque converter clutch and drive

Suspension and axle

• Troubleshooting
• Tire and wheel
• Front wheel alignment
• Rear wheel alignment
• Front axle hub
• Front wheel hub bolt
• Front drive shaft
• Front shock absorber
• Front lower suspension arm
• Front lower ball joint
• Front stabilizer bar
• Rear axle carrier
• Rear wheel hub bolt
• Rear shock absorber
• Rear upper suspension arm
• Rear lower suspension arm
• Rear stabilizer bar

Brake

• Brake system
• Troubleshooting
• Brake fluid
• Brake pedal
• Parking brake lever
• Brake master cylinder
• Brake booster assembly
• Front brake pad
• Front brake caliper
• Rear drum brake
• Rear brake pad
• Rear brake caliper
• Parking brake
• Proportioning valve
• Abs actuator
• Front speed sensor
• Rear speed sensor

Steering

• Steering system
• Troubleshooting
• Drive belt
• Power steering fluid
• Steering wheel
• Tilt steering column
• Power steering vane pump
• Power steering gear

Supplemental restraint system

• SRS airbag
• Steering wheel pad and spiral cable
• Front passenger airbag assembly
• Side airbag assembly
• Airbag sensor assembly
• Front airbag sensor
• Side airbag sensor assembly
• Door side airbag sensor
• Wire harness and connector

Body electrical

• Body electrical
• Troubleshooting
• Power source
• Ignition switch and key unlock warning switch
• Headlight and taillight system
• Headlight beam level control system
• Fog light system
• Turn signal and hazard warning system
• Interior light system
• Back-up light system
• Stop light system
• Wiper and washer system
• Combination meter
• Electric tension reducer system
• Defogger system
• Power window control system
• Power door lock control system
• Wireless door lock control system
• Sliding roof system
• Power mirror control system
• Audio system
• Antenna
• Clock
• Horn system

Body

• Clip
• SRS airbag
• Front bumper
• Rear bumper
• Headlight
• Hood
• Front door
• Back door
• Back door stay
• Front wiper and washer
• Rear wiper and washer
• Roof drip side moulding
• Roof side moulding
• Side mud guard
• Windshield
• Quarter window glass
• Back door glass
• Sliding roof
• Instrument panel
• Roof headlining
• Front seat
• Rear seat
• Seat belt
• Seat belt pretensioner

Air conditioning

• Troubleshooting
• Drive belt
• Manifold gauge set
• Refrigerant line
• Air conditioning unit
• Blower unit
• Compressor and magnetic clutch
• Condenser
• Blower motor
• Blower resistor
• Thermistor
• Pressure switch
• Heater main relay
• Magnetic clutch relay
• Cooling fan relay
• Condenser fan
• Air conditioning amplifier
• Heater control assembly
• Engine coolant temperature switch
• Air refiner filter

Customers reviews