Subaru Legacy 2004 thru 2009, repair e-manual 3 parts
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
(9)
9
10
1
Publisher: © "Motorist"
ISBN: 977-129-542-418-6
Number of pages: 14035
Format: file PDF
About the manual
Engine type: EJ20 / EJ25 / EZ30
Engine capacity: 2.0 / 2.5 / 3.0 l.
In the manual you will find
- Step-by-step guide to repair various components and assemblies
- Self-care and maintenance instructions
- Car design and prevention information
- Information for a trip to the service station, if self-repair is not possible
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
Publisher: © "Motorist"
ISBN: 977-129-542-418-6
Number of pages: 14035
Format: file PDF
About the manual
Engine type: EJ20 / EJ25 / EZ30
Engine capacity: 2.0 / 2.5 / 3.0 l.
In the manual you will find
- Step-by-step guide to repair various components and assemblies
- Self-care and maintenance instructions
- Car design and prevention information
- Information for a trip to the service station, if self-repair is not possible
Content
General information
- Foreword
- How to use this manual
- Specifications
- Precaution
- Note
- Identification
- Recommended materials
- Pre-delivery inspection
- Periodic maintenance services
Fuel injection
- General description
- Throttle body
- Intake manifold assembly
- Engine coolant temperature sensor
- Crankshaft position sensor
- Knock sensor
- Throttle position sensor
- Manifold absolute pressure sensor
- Fuel injector
- Front oxygen (A/F) sensor
- Rear oxygen sensor
- Engine control module (ECM)
- Main relay
- Fuel pump relay
- Fuel
- Fuel tank
- Fuel filler pipe
- Fuel pump
- Fuel level sensor
- Fuel sub level sensor
- Fuel filter
- Fuel delivery and evaporation lines
- Fuel system trouble in general
Emission control
- General description
- Front catalytic converter
- Rear catalytic converter
- EGR alve
- Canister
- Purge control solenoid valve
- Two-way valve
- PCV valve
Intake
- General description
- Air cleaner element
- Air cleaner case
- Air intake duct
- Resonator chamber
Mechanical
- General description
- Compression
- Idle speed
- Ignition timing
- Intake manifold vacuum
- Engine oil pressure
- Fuel pressure
- Valve clearance
- Engine assembly
- Engine mounting
- Preparation for overhaul
- V-belt
- Crank pulley
- Chain cover
- Timing belt cover
- Timing belt
- Cam sprocket
- Crank sprocket
- Valve rocker assembly
- Camshaft
- Cylinder head
- Cylinder block
- Engine trouble in general
- Engine noise
Exhaust
- General description
- Front exhaust pipe
- Center exhaust pipe
- Rear exhaust pipe
- Muffler
Cooling
- General description
- Radiator fan system
- Engine coolant
- Water pump
- Thermostat
- Radiator
- Radiator cap
- Radiator fan and fan motor assembly
- Reservoir tank
- Engine cooling system trouble in general
Lubrication
- General description
- Oil pressure system
- Engine oil
- Oil pump
- Oil pan
- Oil pressure switch
- Engine oil filter
- Engine lubrication system trouble in general
Speed control systems
- General description
- Accelerator Pedal
Ignition
- General description
- Spark plug
- Ignition coil
- Spark plug cord
Starting / charging systems
- General description
- Starter
- Generator
- Battery
Intake
- General description
- Air cleaner element
- Air cleaner case
- Air intake chamber
- Air intake duct
- Resonator chamber
Control systems
- General description
- Select lever
- Select cable
- AT steering shift switch
- Shift lock solenoid
- MT gear shift lever
- MT drive select lever
- Drive select cable
- General diagnostic table
Automatic transmission
- General description
- Automatic transmission fluid
- Differential gear oil
- Road test
- Stall test
- Time lag test
- Line pressure test
- Transfer clutch pressure test
- Automatic transmission assembly
- Transmission mounting system
- Extension case oil seal
- Differential side retainer oil seal
- Inhibitor switch
- Front vehicle speed sensor
- Rear vehicle speed sensor
- Torque converter turbine speed sensor
- Control valve body
- Air bleeding of control valve
- ATF filter
- Transmission control module
- Lateral G sensor
- ATF cooler pipe and hose
- ATF cooler (with warmer function)
- Warmer cock
- Air breather hose
- Oil charge pipe
- Torque converter clutch assembly
- Extension case
- Transfer clutch
- Multi-plate clutch
- Rear drive shaft
- Reduction driven gear
- Reduction drive gear
- Center differential carrier
- Parking pawl
- Converter case
- Oil pump housing
- Drive pinion shaft assembly
- Front differential assembly
- At main case
- Transmission control device
Manual transmission and differential
- General description
- Transmission gear oil
- Manual transmission assembly
- Transmission mounting system
- Oil seal
- Differential side retainer oil seal
- Switches and harness
- Preparation for overhaul
- Transfer case and extension case assembly
- Transfer drive gear
- Transfer driven gear
- Center differential
- Reverse check sleeve
- Transmission case
- Main shaft assembly for single-range
- Main shaft assembly for dual-range
- Input shaft assembly
- Drive pinion shaft assembly
- Front differential assembly
- Reverse idler gear
- Shifter fork and rod
- Counter gear
- General diagnostic table
Clutch system
- General description
- Clutch disc and cover
- Flywheel
- Release bearing and lever
- Operating cylinder
- Master cylinder
- Clutch pipe and hose
- Clutch fluid
- Clutch fluid air bleeding
- Clutch pedal
- Clutch switch
- General diagnostic table
Front suspension
- General description
- Wheel alignment
- Cradle
- Front stabilizer
- Front ball joint
- Front arm
- Front strut
- Front crossmember
- General diagnostic table
Rear suspension
- General description
- Wheel alignment
- Rear stabilizer
- Rear arm
- Upper link
- Rear shock absorber
- Front link
- Rear link
- Sub frame support arm
- Sub frame support plate
- Rear sub frame
- Helper
- General diagnostic table
Wheel and tire system
- General description
- Tire
- Steel wheel
- Aluminum wheel
- Wheel balancing
- General diagnostic table
Differentials
- General description
- Differential gear oil
- Front differential assembly
- Rear differential
- Rear differential front oil seal
- Rear differential side oil seal
- Rear differential front member
- General diagnostic table
Transfer case
- General description
- Transfer clutch
- Extension case
- Oil seal
- Transfer driven gear
- Reduction drive gear
- Reduction driven gear
- Center differential
- Transfer clutch pressure test
Drive shaft system
- General description
- Propeller shaft
- Front axle
- Front hub unit bearing
- Rear axle
- Rear hub unit bearing
- Front drive shaft
- Rear drive shaft
- General diagnostic table
ABS
- General description
- ABS control module and hydraulic control unit
- ABS Sequence Control
- Front ABS wheel speed sensor
- Rear ABS wheel speed sensor
- Front magnetic encoder
- Rear magnetic encoder
Vehicle dynamics control
- General description
- VDC control module and hydraulic control unit
- ABS sequence control
- VDC sequence control
- Yaw rate and lateral G sensor
- Steering angle sensor
- Front ABS wheel speed sensor
- Rear ABS wheel speed sensor
- Front magnetic encoder
- Rear magnetic encoder
- VDC off switch
Brake
- General description
- Front brake pad
- Front disc rotor
- Front disc brake assembly
- Rear brake pad
- Rear disc rotor
- Rear disc brake assembly
- Master cylinder
- Brake booster
- Brake fluid
- Air bleeding
- Brake hose
- Brake pipe
- Brake pedal
- Stop light switch
- Diagnosis
Parking brake
- General description
- Parking brake lever
- Parking brake cable
- General diagnostic table
Power assisted system (power steering)
- General description
- Steering wheel
- Universal joint
- Steering gearbox
- Pipe assembly
- Oil pump
- Reservoir tank
- Power steering fluid
- General diagnostic table
HVAC system (heater, ventilator and A/C)
- General description
- Refrigerant pressure with manifold gauge set
- Refrigerant recovery procedure
- Refrigerant charging procedure
- Refrigerant leak check
- Compressor oil
- Blower motor unit assembly
- Blower motor
- Power transistor (auto A/C model)
- Blower resistor (manual A/C model)
- Heater core
- Control unit
- Compressor
- Condenser
- Heater and cooling unit
- Evaporator
- Relay and fuse
- Pressure switch
- Ambient sensor
- Sunload sensor (auto A/C model)
- In-vehicle sensor (auto A/C model)
- Air vent grille
- Heater duct
- Heater vent duct
- Heater cock solenoid valve
- General diagnostic table
Airbag system
- General description
- Airbag connector
- Inspection locations after a collision
- Driver’s airbag module
- Passenger’s airbag module
- Side airbag module
- Curtain airbag module
- Airbag control module
- Side airbag sensor
- Curtain airbag sensor
- Roll connector
- Airbag module disposal (deployment processing on vehicle)
Seat belt system
- General description
- Pretensioner connector
- Inspection locations after a collision
- Seat belt warning system
- Front seat belt
- Rear seat belt
- Disposal of pretensioner
Lighting system
- General description
- Headlight and tail light system
- Front fog light system
- Rear fog light system
- Turn signal light and hazard light system
- Back-up light system
- Stop light system
- Room light system
- Combination switch (light)
- Headlight beam leveler system
- Combination base switch assembly
- Headlight assembly
- Headlight bulb
- Front turn signal light bulb
- Clearance / parking light bulb
- Front fog light assembly
- Front fog light bulb
- Rear fog light
- Side turn signal light assembly
- Rear combination light assembly
- Tail / stop light bulb
- Rear turn signal light bulb
- Back-up light assembly
- Back-up light bulb
- Rear fog light bulb
- License plate light assembly
- License plate light
- High-mounted stop light
- Spot map light
- Room light
- Luggage room light
- Trunk room light
- Glove box light
- Door step light
- Ignition switch illumination
Wiper and washer systems
- General description
- Wiper and washer system
- Combination switch (wiper)
- Wiper blade
- Washer tank and motor
- Front wiper arm
- Front wiper motor and link
- Front washer nozzle
- Rear wiper arm
- Rear wiper motor
- Rear washer
Entertainment and monitoring
- General description
- Audio system
- Audio
- Front speaker
- Rear speaker
- Woofer
- Power amplifier
- Antenna
- Noise suppressor
- Navigation display
- GPS antenna
- Navigation body
- Front accessory power supply socket
- Steering satellite switch
Communication system
- General description
- Horn system
- Horn
- Horn switch
Glass / windows / mirrors
- General description
- Power window system
- Power window control switch
- Front door glass
- Front regulator and motor assembly
- Remote control mirror system
- Scalp cap
- Outer mirror assembly
- Outer mirror
- Remote control mirror switch
- Rear door glass
- Rear regulator and motor assembly
- Windshield glass
- Rear gate glass
- Rear window glass
- Rear window defogger system
- Rear window defogger
- Rear quarter glass
- Sun roof glass
- Rearview mirror
- Wiper deicer system
- Wiper deicer switch
Body structure
Instrumentation / driver info
- General description
- Combination meter system
- Clock system
- Combination meter assembly
- Speedometer
- Tachometer
- Fuel gauge
- Water temperature gauge
- Clock
Seats
- General description
- Front seat
- Rear seat
- Seat heater system
Security and locks
- General description
- Door lock control system
- Keyless entry system
- Front inner remote
- Front outer handle
- Front door latch and door lock actuator assembly
- Rear inner remote
- Rear outer handle
- Rear door latch and door lock actuator assembly
- Rear gate opener button
- Rear gate latch and actuator assembly
- Trunk lid lock assembly
- Front hood lock assembly
- Remote openers
- Ignition key lock
- Key lock cylinders
- Keyless entry control module
- Body integrated unit
- Keyless transmitter
- Immobilizer control unit
- Immobilizer antenna
Sunroof
- General description
- Sunroof control system
- Glass lid
- Sunroof assembly
- Sunroof motor
- Sunroof switch
Exterior / interior trim
- Front grille
- Front hood grille
- Front under cover
- Floor under protector
- Fuel tank protector
- Mud guard
- Front bumper
- Rear bumper
- Cowl panel
- Roof spoiler
- Side sill spoiler
- Side protector
- Side garnish
- Rear quarter protector
- Roof molding
- Roof rail
- Door trim
- Instrument panel lower cover
- Glove box
- Console box
- Center console
- Instrument panel assembly
- Lower inner trim
- Upper inner trim.
- Rear quarter trim
- Sun visor
- Assist grip
- Roof trim
- Rear gate trim
- Rear shelf trim
- Trunk room trim
- Floor mat
- Luggage floor box
- Trunk lid garnish
- Rear gate garnish
- Heat shield cover
- Ornament
Exterior body panels
- General description
- Front hood
- Front fender
- Front door
- Front sealing cover
- Rear door
- Rear sealing cover
- Trunk lid
- Rear gate
Cruise control system
- General description
- Control unit
- Cruise control command switch
- Combination meter
- Inhibitor switch
- Neutral position switch
Immobilizer
Lan system
Wiring system
- Basic diagnostic procedure
- Working precautions
- Power supply circuit
- Ground distribution circuit
- Airbag system
- Air conditioning system
- Anti-lock brake system
- At control system
- Audio system
- Can communication system
- Charging system
- Clock system
- Combination meter
- Cruise control system
- Coolant temperature system
- Engine electrical system
- Fuel gauge system
- Full time dual-range system
- Front accessory power supply socket system
- Headlight beam leveler system
- Horn system
- Immobilizer system
- Keyless entry system
- Back-up light system
- Clearance light and illumination light system
- Front fog light system
- Headlight system
- Interior light system
- Rear fog light system
- Stop light system
- Turn signal light and hazard light system
- Navigation system
- Oil pressure warning light system
- Parking brake / brake fluid level warning light system
- Power seat system
- Power window system
- Radiator fan system
- Rear window defogger system
- Remote control mirror system
- Seat belt warning system
- Seat heater system
- Starter system
- Sunroof system
- Vehicle dynamics control system
- Front wiper and washer system
- Rear wiper and washer system
- Wiper deicer system
- Alarm control system
- Rear accessory power supply system
- Harness components location
- Front wiring harness
- Bulkhead wiring harness (in engine compartment)
- Bulkhead wiring harness (in compartment)
- Engine wiring harness and transmission cord
- Instrument panel wiring harness
- Rear wiring harness
- Door cord
- Rear wiring harness and trunk lid cord
- Rear wiring harness and rear gate cord
Customers reviews
from Иван on 12/11/2024
Столкнулся с течью в системе охлаждения. Благодаря книге быстро нашел схему патрубков и обнаружил поврежденный шланг. Заменил сам, сэкономив на ремонте
