Skandic WT / SWT REV-XU snowmobile, repair e-manual

Content

Safety notice

Introduction

• Vehicle information
• Manual information
• Fastener information

Maintenance

• Break-in inspection
• Periodic maintenance schedule
• Periodic maintenance procedures
• Storage procedure
• Preseason preparation

Engine (550F)

• Engine removal and installation
• Engine leak test
• Engine measurement
• Air intake system
• Exhaust system
• Lubrication system.
• Rewind starter
• Axial fan
• Magneto system
• Top end
• Bottom end

Engine (600 HO E-TEC)

• Engine removal and installation
• Engine leak test
• Engine measurement
• Air intake system
• Exhaust system
• Lubrication system
• Cooling system
• Magneto system
• Rave
• Top end
• Bottom end

Engine (600 ACE)

• Engine removal and installation
• Air intake system
• Exhaust system
• Lubrication system
• Cooling system
• Magneto and starter
• Timing chain
• Cylinder head
• Cylinder block

Electronic management systems

• Engine management (600 HO E-TEC)
• Engine management (600 ACE)
• Controller area network (can)
• Communication tools and B.U.D.S
• Diagnostic and fault codes (600 HO E-TEC and 600 ACE)

Fuel system

• Fuel tank and fuel pump (550F)
• Fuel tank and fuel pump (600 HO E-TEC and 600 ACE)
• Vm carburetors, throttle and choke cables (550F)
• E-tec direct fuel injection
• Electronic fuel injection (600 ACE)

Electrical system

• Power distribution and grounds (550F)
• Power distribution and grounds (600 HO E-TEC)
• Power distribution and grounds (600 ACE)
• Ignition system (550F)
• Ignition system (600 HO E-TEC))
• Ignition system (600 ACE))
• Charging system (550F))
• Charging system (600 HO E-TEC))
• Charging system (600 ACE))
• Starting system (550F))
• Starting system (600 HO E-TEC))
• Starting system (600 ACE))
• Digitally encoded security system (D .E.S .S.))
• Lights, gauge and accessories)
• Volt power outlet

Drive system and brake

• Drive belt
• Drive pulley (edrive)
• Drive pulley (tra ill)
• Driven pulley and countershaft (550F and 600 ACE)
• Driven pulley and countershaft (600 HO E-TEC)
• Brake
• Gearbox
• Drive axle
• Track

Chassis

• Front suspension (Xu-Lts)
• Rear suspension (Sc-5u)
• Steering system

Body

• Frame

Technical specifications

• Skandic WT (550F)
• Skandic WT / SWT (600 HO E-TEC)
• Skandic WT / SWT (600 ACE)

Wiring diagram

• Wiring diagram information
• Connector information

Customers reviews