Renault Twingo (MR411 / MR412 / MR413) since 2009, repair e-manual

Content

General vehicle information

• Vehicle mechanical specifications
• Vehicle bodywork specifications
• Mechanical introduction
• Lifting equipment
• Collision
• Consumables - products
• Paint

Engine and peripherals

• Engine and cylinder block assembly
• Top and front of engine

Fuel mixture

• Air inlet
• Air filter
• Air filter unit
• Air resonator
• Throttle valve
• Air flowmeter
• Inlet distributor
• Injector holder shim
• Exhaust manifold

Turbocharging

• Air inlet
• Intercooler
• Fuel supply
• Diesel supply circuit
• Manual priming pump
• Fuel filter
• Electric diesel fuel heater
• Fuel pressure
• Fuel flow
• Diesel injection
• Injector leak flow
• Accelerometer

Preheating

• Pre-postheating unit
• Heater plugs

Antipollution

• Oil vapour rebreathing circuit
• Fuel vapour recirculation circuit
• Fuel vapour absorber
• Fuel vapour absorber bleed solenoid valve
• Exhaust gas cooler

Starting - charging

• Alternator
• Starter

Ignition

• Coils
• Plugs

Petrol injection

• Petrol injection
• Oxygen sensors
• Petrol injection computer
• Pinking sensor
• Crankshaft position sensor
• Injector rail - injectors
• Cooling
• Engine cooling system
• Cooling radiator
• Coolant pump
• Thermostat
• Water chamber
• Engine cooling fan assembly
• Coolant pump inlet pipe
• Expansion bottle
• Coolant temperature sensor

Exhaust

• Catalytic converter
• Expansion chamber
• Intermediate pipe
• Silencer

Tank

• Fuel tank
• Filler neck
• Fuel level sensor module

Engine mounting

• Suspended engine mounting
• Left-hand suspended engine mounting
• Right-hand suspended engine mounting
• Lower engine tie-bar

Clutch

• Pressure plate
• Clutch thrust bearing

Manual gearbox

• Manual gearbox oil
• Manual gearbox
• Differential output seal
• Input shaft lip seal
• Reverse gear switch

Sequential gearbox

• Sequential gearbox oil
• Pressure accumulator
• Pump assembly reservoir
• Electro-hydraulic unit
• Pump assembly
• Solenoid valves
• Engagement sensor
• Actuator module
• Gear selection sensor
• Clutch position sensor
• Solenoid valve assembly pressure sensors
• Sequential gearbox engine speed sensor
• Sequential gearbox converter
• Sequential gearbox gear lever

Driveshafts

• Front left-hand driveshaft
• Front right-hand driveshaft
• Relay shaft bearing
• Front driveshaft gaiter, wheel side
• Front right-hand driveshaft gaiter, gearbox side
• Front left-hand driveshaft gaiter, gearbox side

Front axle components

• Front brake pads
• Front brake hose
• Front brake calliper
• Front brake calliper mounting
• Front brake disc protector
• Front brake disc
• Front driveshaft hub carrier
• Front hub carrier bearing
• Front shock absorber and spring
• Front driveshaft lower arm
• Front driveshaft lower arm ball joint
• Front axle subframe
• Radiator mounting cross member
• Front anti-roll bar

Rear axle components

• Rear brake pads
• Rear brake hose
• Rear brake calliper
• Rear brake calliper mounting
• Rear brake disc
• Rear brake lining
• Rear brake cylinder
• Rear brake drum
• Rigid brake pipe
• Shock absorber
• Rear suspension spring
• Rear drum bearing
• Rear stub axle carrier
• Complete rear axle system

Wheels and tyres

• Wheel
• Tyres
• Tyre pressure
• Wheel rim

Steering assembly

• Steering box
• Track rod
• Axial ball joint linkage
• Steering column
• Steering box gaiter
• Bulkhead seal
• Intermediate shaft
• Steering wheel
• Power assisted steering

Mechanical component controls

• Master cylinder
• Brake servo non-return valve
• Brake servo
• Vacuum pump
• Pedal assembly
• Accelerator pedal
• Brake pedal
• Brake pedal switch
• Parking brake lever
• Clutch control
• Clutch cable
• Clutch pedal switch
• Clutch circuit
• Clutch master cylinder
• Clutch circuit
• Manual gear control
• Gear control unit
• Parking brake cables

Anti-lock braking system

• Hydraulic brake unit
• Front wheel speed sensor
• Rear wheel speed sensor
• Lateral acceleration and yaw sensor
• Braking computer

Panelwork

• General information
• Front lower structure
• Centre lower structure
• Side lower structure
• Rear lower structure
• Front upper structure
• Side upper structure
• Rear upper structure
• Top of body
• Side opening elements
• Non-side opening elements

Heating

• Cabin filter
• Front side air distribution duct
• Front centre air distribution duct
• Front footwell air distribution duct
• Recirculation control cable
• Air distribution cable
• Air mixing cable
• Distribution unit
• Heater matrix
• Fan assembly
• Heating resistors
• Passenger compartment fan assembly control unit
• Control panel
• Recirculation motor
• Mixing motor
• Distribution motor
• Passenger compartment temperature sensor

Air conditioning

• Refrigerant circuit
• Condenser
• Dehydrator reservoir
• Compressor
• Expansion valve
• Evaporator
• Dehydrator reservoir
• Pressure sensor
• Exterior air temperature sensor

Opening element sealing

• Door sealing film
• Side opening elements double seal

Window sealing

• Front side door window run channel
• Front side door exterior weatherstrip

Trim and upholstery

• Body internal trim
• Side opening element trim
• Non-side opening elements trim
• Front seat frames and mechanisms
• Rear seat frames and mechanisms
• Front seat trim
• Rear seat trim
• Seat accessories

Electrical equipment

• Battery
• Headlights
• Rear lighting
• Interior lighting
• Fuses
• Engine immobiliser
• Horn
• Instrument panel
• Cruise control
• Control - signals
• Wiping - washing

Customers reviews