Nissan Silvia / 200sx (S15) 1999 thru 2002, repair e-manual

Content

General information

• Precautions
• How to use this manual
• How to read wiring diagrams
• How to perform efficient diagnosis for an electrical incidentm
• How to follow trouble diagnoses
• Consult-ii checking system
• Identification information
• Lifting points and tow truck towing
• Tightening torque of standard bolts

Maintenance

• Pre-delivery inspection items
• General maintenance
• Periodic maintenance
• Recommended fluids and lubricants

Engine mechanical

• Precautions
• Preparation
• Noise, vibration and harshness (NVH) troubleshooting
• Outer component parts
• Measurement of compression pressure
• Air cleaner
• Spark plug
• Oil pan
• Timing chain
• Oil seal
• Intake manifold
• Cylinder head
• Turbocharger
• Charge air cooler
• Engine assembly
• Cylinder block
• Service data and specifications

Engine lubrication and cooling systems

Engine control system

• Index for DTC
• Precautions
• Preparation
• Engine and emission control overall system
• Basic service procedure
• On board diagnostic system description
• Trouble diagnosis - introduction
• Trouble diagnosis - basic inspection
• Trouble diagnosis - general description
• Trouble diagnosis for intermittent incident
• Trouble diagnosis for power supply
• Heated oxygen sensor
• Vehicle speed sensor
• Idle air control valve (IACV) - auxiliary air control (AAC) valve
• Intake valve timing control solenoid valve
• Wastegate valve control solenoid valve
• Park/neutral position (PNP) switch
• Injector
• Start signal
• Fuel pump
• Iacv-ficd solenoid valve
• Power steering oil pressure switch
• Electrical load signal
• Mi and data link connectors
• Service data and specifications

Accelerator control, fuel and exhaust systems

• Preparation
• Accelerator control system
• fuel system
• Exhaust system

Clutch

• Precautions
• Preparation
• Noise, vibration and harshness (NVH) troubleshooting
• Clutch system - hydraulic type
• Clutch master cylinder
• Operating cylinder
• Piping
• Clutch release mechanism
• Clutch disc, clutch cover and flywheel
• Service data and specifications

Manual transmission

• Precautions
• Preparation
• Noise, vibration and harshness (NVH) troubleshooting
• M/T oil
• On-vehicle service
• Description
• Shift control
• Removal and installation
• Repair for component parts
• Service data and specifications

Automatic transmission

• Precautions
• Preparation
• Overall system
• On board diagnostic system description
• Trouble diagnosis - introduction
• Trouble diagnosis - basic inspection
• Trouble diagnosis - general description
• A/T shift lock system
• Key interlock cable
• Shift control system
• On-vehicle service
• A/T shift lock system
• Key interlock cable
• On-vehicle service
• A/T fluid cooler system
• Service data and specifications

Propeller shaft and differential carrier

• Propeller shaft
• Rear final drive

Front and rear axle

Front and rear suspension

Brake system

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• On-vehicle service
• Brake hydraulic line
• Proportioning valve
• Brake pedal and bracket
• Master cylinder
• Brake booster
• Vacuum piping
• Front disc brake
• Rear disc brake
• Parking brake control
• Service data and specifications

Steering system

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• On-vehicle service
• Steering wheel and steering column
• Power steering gear and linkage
• Power steering oil pump
• Service data and specifications

Restraint system

• Seat belts
• Supplemental restraint system

Body and trim

• Precautions
• Clip and fastener
• Body front end
• Body rear end and opener
• Door
• Instrument panel assembly
• Side and floor trim
• Door trim
• Roof trim
• Trunk room trim
• Exterior
• Front seat
• Rear seat
• Sunroof
• Windshield and windows
• Door mirror
• Body (alignment)

Heater and air conditioner

• Precautions
• Preparation
• Description
• Trouble diagnoses
• Wheel and tire assembly
• Service procedure
• Service data and specifications

Starting and charging system

• Precautions
• Battery
• Starting system
• Charging system
• Service data and specifications

Electrical system

• Precautions
• Harness connector
• Standardized relay
• Power supply routing
• Ground
• Combination switch
• Headlamp
• Parking, license and tail lamps
• Stop lamp
• Back-up lamp
• Turn signal and hazard warning lamps
• Illumination
• Interior room lamp
• Spot and trunk room lamps
• Meters and gauges
• Warning lamps
• A/T indicator
• Warning buzzer
• Front wiper and washer
• Horn
• Cigarette lighter
• Clock
• Rear window defogger
• Audio
• Audio antenna
• Power sunroof
• Door mirror
• Power window
• Power door lock
• Unified meter control unit (time control system)
• NATS (Nissan anti-theft system
• Electrical units location
• Harness layout
• Bulb specifications
• Wiring diagram codes (cell codes)

Customers reviews