Nissan Quest since 2007, repair e-manual

Content

General information

• Precautions
• How to use this manual
• Service information for electrical incident
• Tconsult-II checking system
• Lifting point
• Tow truck towing
• Tightening torque of standard bolts
• Recommended chemical products and sealants
• Identification information
• Terminology

Engine mechanical

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Drive belts
• Air cleaner and air duct
• Intake manifold collector
• Egr volume control valve
• Intake manifold
• Exhaust manifold and three way catalyst
• Oil pan and oil strainer
• Ignition coil
• Spark plug (platinum-tipped type)
• Fuel injector and fuel tube
• Rocker cover
• Front timing chain case
• Timing chain
• Camshaft
• Oil seal
• Cylinder head
• Engine assembly
• Cylinder block
• Service data and specifications (SDS)

Engine lubrication system

• Precautions
• Preparation
• Lubrication system
• Engine oil
• Oil filter
• Oil pump
• Oil cooler
• Service data and specifications (SDS)

Engine cooling system

• Precautions
• Preparation
• Overheating cause analysis
• Engine coolant
• Radiator
• Cooling fan
• Water pump
• Thermostat and thermostat housing
• Water outlet and water piping
• Service data and specifications (SDS)

Engine control system

• Index for DTC
• Precautions
• Preparation
• Engine control system
• Air conditioning cut control
• Automatic speed control device
• Can communication
• Evaporative emission system
• On board refueling vapor recovery (ORVR)
• Positive crankcase ventilation
• NVIS (Nissan vehicle immobilizer system-NATS)
• On board diagnostic (OBD) system
• Basic service procedure
• Trouble diagnosis
• Power supply and ground circuit
• Electrical load signal
• Electronic controlled engine mount
• Fuel injector
• Fuel pump
• Ignition signal
• Refrigerant pressure sensor
• VIAS
• Mil and data link connector
• Service data and specifications (SDS)

Fuel system

• Precautions
• Preparation
• Fuel system
• Fuel level sensor unit, fuel filter and fuel pump assembly
• Fuel tank
• Service data and specifications (SDS)

Exhaust system

• Preparation
• Exhaust system

Accelerator control system

• Precautions
• Accelerator control system
• Service data and specifications (SDS)

Transmission/ transaxle

• Index for DTC
• Precautions
• Preparation
• A/T fluid
• A/T control system
• On board diagnostic (OBD) system
• Trouble diagnosis
• A/T shift lock system
• Shift control system
• Key interlock cable
• On-vehicle service
• Service data and specifications (SDS)

Front axle

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Front wheel hub and knuckle
• Front drive shaft
• Service data and specifications (SDS)

Rear axle

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Wheel hub
• Service data and specifications (SDS)

Front suspension

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Front suspension assembly
• Coil spring and shock absorber
• Stabilizer bar
• Transverse link
• Front suspension member
• Service data and specifications (SDS)

Rear suspension

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Rear suspension assembly
• Rear suspension member
• Shock absorber
• Suspension arm
• Radius rod
• Front lower link
• Rear lower link and coil spring
• Stabilizer bar
• Service data and specifications (SDS)

Road wheels and tires

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Road wheel
• Road wheel tire assembly
• Low tire pressure warning system
• Can communication
• Trouble diagnoses
• Trouble diagnosis for self-diagnostic items
• Service data and specifications (SDS)

Brake system

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Brake pedal
• Brake fluid
• Brake piping and hose
• Brake master cylinder
• Brake booster
• Vacuum lines
• Front disc brake
• Rear disc brake
• Service data and specifications (SDS)

Parking brake system

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Parking brake system
• Parking brake shoe
• Service data and specifications (SDS)

Brake control system

• TCS / ABS
• VDC / TCS / ABS

Power steering system

• Precautions
• Preparation
• Noise, vibration, and harshness (NVH) troubleshooting
• Power steering fluid
• Steering wheel
• Steering column
• Power steering gear and linkage
• Power steering oil pump
• Hydraulic line
• Service data and specifications (SDS)

Supplemental restraint system (SRS)

• Precautions
• Preparation
• Supplemental restraint system
• Trouble diagnosis
• Driver air bag module
• Spiral cable
• Front passenger air bag module
• Side curtain air bag module
• Crash zone sensor
• Side air bag (satellite) sensor
• Diagnosis sensor unit
• Occupant classification system control unit

Body, lock and security system

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Hood
• Power door lock system
• Remote keyless entry system
• Vehicle security (theft warning) system
• Automatic sliding door system
• Automatic back door system
• Door
• Front door lock
• Slide door lock
• Back door lock
• Fuel filler lid opener
• NVIS(Nissan vehicle immobilizer system-NATS)
• Homelink universal transceiver
• Body repair

Glasses, window system and mirrors

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Windshield glass
• Rear window glass and molding
• Skyview roof
• Power window system
• Front door glass and regulator
• Slide door glass
• Side window glass
• Inside mirror
• Rear window defogger

Roof

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Sunroof

Exterior and interior

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Clip and fastener
• Front bumper
• Rear bumper
• Front grille
• Cowl top
• Front fender
• Fender protector
• Mudguard
• License lamp finisher
• Roof rack
• Roof side molding
• Door outside molding
• Side guard molding
• Door finisher
• Body side trim
• Floor trim
• Headlining

Instrument panel

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Instrument panel assembly
• Center console assembly

Seat

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Automatic drive positioner
• Power seat
• Heated seat
• Front seat
• Rear seat

Automatic air conditioner

• Precautions
• Preparation
• Refrigeration system
• Air conditioner control
• Trouble diagnosis
• Control unit
• Ambient sensor
• In-vehicle sensor
• Optical sensor
• Intake sensor
• Blower motor
• In-cabin microfilter
• Heater and cooling unit assembly
• Heater core
• Heater pump
• Defroster door motor
• Intake door motor
• Mode door motor
• Air mix door motor
• Variable blower control
• Ducts and grilles
• Refrigerant lines
• Service data and specifications (SDS)

Manual air conditioner

• Precautions
• Preparation
• Refrigeration system
• Air conditioner control
• Trouble diagnosis
• Control unit
• Ambient sensor
• In-vehicle sensor
• Optical sensor
• Intake sensor
• Blower motor
• In-cabin microfilter
• Heater and cooling unit assembly
• Heater core
• Heater pump
• Defroster door motor
• Intake door motor
• Mode door motor
• Air mix door motor
• Variable blower control
• Ducts and grilles
• Refrigerant lines
• Service data and specifications (SDS)

Starting and charging system

• Precautions
• Preparation
• Battery
• Starting system
• Charging system
• Service data and specifications (SDS)

Lighting system

• Precautions
• Headlamp (for USA)
• Headlamp (for Canada) - daytime light system
• Auto light system
• Front fog lamp
• Turn signal and hazard warning lamps
• Cornering lamp
• Lighting and turn signal switch
• Hazard switch
• Combination switch
• Back-up lamp
• Parking, license plate and tail lamps
• Rear combination lamp
• Trailer tow
• Interior room lamp
• Illumination
• Bulb specifications

Driver information system

• Precaution
• Preparation
• Combination meters
• Warning lamps
• A/T indicator
• Warning chime
• Rear sonar system
• Rear view monitor

Wiper, washer and horn

• Precaution
• Front wiper and washer system
• Rear wiper and washer system
• Power socket
• Horn

Body control system

• Precautions
• BCM (body control module)

Audio visual, navigation and telephone system

• Precautions
• Preparation
• Audio
• Audio antenna
• DVD entertainment system
• Integrated display system
• Navigation system
• Telephone

Auto cruise control system

Power supply, ground and circuit elements

• Precautions
• Power supply routing circuit
• Ipdm E/R (intelligent power distribution module engine room)
• Ground circuit
• Harness
• Electrical units location
• Harness connector
• Electrical units
• Standardized relay
• Super multiple junction
• Fuse block-junction box
• Fuse and fusible link box

Maintenance

• Precautions
• Preparation
• General maintenance
• Periodic maintenance
• Recommended fluids and lubricants
• Engine maintenance
• Chassis and body maintenance

Alphabetical index

Customers reviews