Mitsubishi Lancer IX 2000 thru 2007, repair e-manual (in Russian)

Contents

Interior

• Special tools
• Instrument panel
• Floor console
• Trim
• Interior rearview mirror
• Seats
• Seat belt

Supplemental restraint system

Heater, air conditioning, and ventilation system

• Basic adjustment and check data
• Lubricants
• Special tools
• Troubleshooting
• Vehicle maintenance
• Heater controls and air conditioning switch
• Heater, radiator, and fan heater, evaporator
• Heater blower motors and air intake dampers
• Evaporator
• Compressor assembly and tensioner pulley
• Condenser and condenser fan motor
• Refrigerant lines
• Air ducts
• Air intakes

Component locations

• Electronic control units
• Relays
• Sensors
• Fuses and links
• Solenoid valves
• Diode
• Ground connections
• Service connector and backup connector

Harness and connector distribution diagram

• General location of electrical components
• Engine compartment
• Engine and transmission
• Instrument panel
• Floor and ceiling
• Doors
• Trunk
• Tailgate

General information

• How to use this manual
• Troubleshooting process / check points
• Components containing vehicle identification markings
• Main specifications
• Servicing precautions
• Supplemental restraint system (SRS)
• SRS servicing precautions
• Jack and lift foot installation locations
• Standard tightening torques for threaded connections

Wiring diagrams and routing diagrams

• Electrical diagrams and contents
• Wire harness routing diagrams
• Wiring diagrams
• Connector and ground markings
• Wire color codes
• List of abbreviations

Engine, mechanical

• General information
• Technical data for service personnel
• Sealing materials
• Special tools
• On-vehicle operations
• Crankshaft pulley
• Camshaft and valve stem caps
• Oil pan
• Crankshaft oil seal
• Cylinder head gasket
• Timing belt
• Engine

Engine lubrication system

• General information
• Inspection and adjustment data
• Applicable oils
• Sealants
• Special tools and fixtures
• On-vehicle maintenance operations

Engine electrical equipment

• System power supply
• Electric starting system
• Ignition system

Clutch

Manual transmission

• General information
• Main technical specifications
• Control dimensions
• Snap ring, adjusting ring, thrust plate
• Tightening torques
• Sealants and adhesives
• Lubricants
• Special tools
• Gearbox
• Primary shaft
• Secondary shaft
• Reverse idler gear
• Speedometer drive gear
• Selector lever gearbox
• Gear selector mechanism
• Clutch housing
• Gearbox housing
• Differential

Automatic transmission

• General information
• Main technical specifications
• Control dimensions
• Snap ring, adjusting ring, thrust ring, thrust washer, and pressure plate
• Tightening torques
• Sealants
• Special tool
• Gearbox
• Hydraulic fluid pump
• Low gear clutch and input shaft
• Reverse and overdrive clutch
• Planet carrier assembly
• Brake for engaging low gear and reverse gear
•  
• Auxiliary brake
• Output shaft
• Differential
• Hydraulic distributor
• Input shaft seal

Exterior

• Bumper
• Moldings
• Side skirts
• Linings
• Spoiler
• Roof rails
• Wiper and washer
• Emblems
• Outside rearview mirrors

Electrical equipment

• Battery battery
• Ignition switch

SWS electrical system without monitoring

SWS electrical system with monitoring

Body

• Hood
• Fenders
• Glass
• Doors
• Trunk lid
• Rear door

Front axle

• General information
• Test parameters
• Lubricants
• Special tools
• Maintenance without disassembly
• Front wheel hub
• Drive shaft

Rear axle

• General information
• Control parameters
• Lubricants
• Special tools
• Maintenance without disassembly
• Rear wheel hub

Tires and wheels

• General information
• Specifications
• Troubleshooting
• Technical operations on the vehicle
• Tires and wheels

Front suspension

• General information
• Basic data for repair and adjustment
• Lubricants
• Special tools tools
• Vehicle maintenance
• Telescopic strut
• Lower control arm
• Stabilizer bar

Rear suspension

• General information
• Basic repair and adjustment data
• Lubricants
• Special tools
• Vehicle maintenance
• Control arm, upper and lower suspension arms
• Trailing arm
• Shock absorber
• Stabilizer bar

Main brake system

• General information
• Basic adjustment data and control
• Lubricants
• Special tools
• On-vehicle maintenance
• Brake pedal
• Master cylinder assembly and vacuum booster
• Front disc brake
• Rear disc brake

Anti-lock braking system

Parking brake

Power steering

• General information
• Basic data for adjustments and control
• Lubricants
• Special tools
• On-vehicle maintenance
• Steering wheel
• Steering column shaft
• Power steering gear and steering linkage
• Power steering pump
• Power steering hoses

Supplemental passive restraint system

Intake and exhaust systems

• General information
• Inspection and adjustment data
• Special tools and accessories
• Air filter
• Intake manifold
• Exhaust manifold
• Exhaust system and main muffler

Powertrain mount in the engine compartment

Fuel supply system

Accelerator drive and emission control systems

Distributed fuel supply system Injection

Engine overhaul

• How to use this manual
• General information
• Main technical data
• Technical data for service personnel
• Overhaul dimensions
• Tightening torques
• Sealing materials
• Special tools
• Alternator and ignition system
• Timing belt
• Fuel and emission control system components
• Cooling pump and hoses
• Intake and exhaust manifolds
• Rocker arms and camshaft
• Cylinder head and valves
• Oil pan and oil pump
• Piston and connecting rod
• Crankshaft and cylinder block

Customers reviews