Jaguar XK (X150) 2005 thru 2009, repair e-manual

Content

General information

• Service information
• General information
• Identification codes
• Jacking and lifting
• Noise, vibration and harshness

Suspension

• Suspension system - general information
• Noise, vibration and harshne
• Front toe adjustment
• Four-wheel alignment
• Wheel alignment angles
• Front suspension
• Front shock absorber
• Rear lower arm
• Rear lower arm bushing
• Front stabilizer bar
• Front stabilizer bar link
• Stabilizer bar link bushing
• Upper arm
• Front wheel bearing and wheel hub
• Wheel knuckle
• Rear suspension
• Lower arm
• Rear shock absorber
• Rear stabilizer bar
• Rear stabilizer bar link
• Rear wheel bearing
• Wheels and tires
• Tire pressure monitoring system
• Tire low pressure sensor
• Vehicle dynamic suspension
• Adaptive damping module
• Rear suspension vertical accelerometer
• Driveline
• Driveline system - general information
• Driveshaft runout and balancing
• Driveshaft
• Rear drive axle / differential
• Axle assembly
• Axle housing bushing
• Drive pinion seal
• Rear drive halfshafts
• Rear halfshaft

Brake system

• Brake system - general information
• General procedures
• Brake disc runout check
• Brake system bleeding
• Front disc brake
• Brake caliper
• Brake disc
• Brake pads
• Rear disc brake
• Brake caliper
• Parking brake and actuation
• Parking brake
• Parking brake cable
• Parking brake module
• Parking brake release actuator
• Parking brake switch
• Hydraulic brake actuation
• Brake master cylinder
• Brake fluid reservoir
• Brake pedal and bracket
• Power brake actuation
• Brake booster
• Anti-lock control
• Anti-lock brake system module
• Front wheel speed sensor
• Hydraulic control unit
• Rear wheel speed sensor
• Yaw rate sensor and accelerometer

Steering system

• Steering system - general information
• Power steering system bleeding
• Power steering
• Power steering fluid cooler
• Power steering fluid reservoir
• Power steering pump
• Steering gear bushing
• Steering angle sensor
• Steering linkage
• Steering gear boot
• Tie rod end
• Steering column
• Steering column lower shaft
• Steering wheel
• Clockspring
• Steering column switches
• Steering column lock actuator
• Steering column multifunction

Engine system - general information

• camshaft bearing
• Camshaft end play
• Camshaft lobe lift
• Camshaft surface
• Connecting rod
• Cylinder head
• Piston pin
• Piston ring
• Valve stem
• Valve clearance
• Engine oil
• Crankshaft main bearing carrier
• Camshafts
• Crankshaft front seal
• Crankshaft pulley
• Crankshaft rear seal
• Engine front cover
• Engine mount
• Exhaust manifold
• Oil pan
• Oil pump
• Timing drive components
• Valve cover
• Oil filter housing
• Oil level
• Oil cooler
• Twin oil coolers
• Valve clearance

Engine cooling

• Cooling system draining, filling and bleeding
• Cooling system draining and vacuum filling
• Cooling system flushing
• Engine cooling
• Coolant expansion tank
• Cooling fan motor and shroud
• Radiator
• Thermostat
• Coolant manifold
• Coolant pump
• Supercharger cooling
• Coolant pump
• Radiator

Fuel charging and controls

• Fuel injection supply manifold
• Fuel injector
• Throttle body

Accessory drive

• Accessory drive belt
• Accessory drive belt tensioner
• Accessory drive belt idler pulley
• Supercharger belt
• Supercharger belt tensioner
• Supercharger belt idler pulley

Starting system

• Starter motor
• Start control unit

Engine ignition

• Spark plugs
• Ignition coil-on-plug

Engine emission control

• Exhaust gas recirculation valve
• Positive crankcase ventilation valve
• Secondary air injection control valve to exhaust manifold tube
• Secondary air injection control valve
• Secondary air injection pump
• Secondary air injection manifold absolute pressure

Intake air distribution and filtering

• Air cleaner
• Intake air resonator
• Charge air cooler
• Supercharger
• Supercharger outlet pipe
• Throttle body elbow

Evaporative emissions

• Evaporative emission canister
• Evaporative emission canister purge valve

Electronic engine controls

• Powertrain control module long drive cycle self
• Powertrain control module short drive cycle self
• Electronic engine controls
• Camshaft position sensor
• Catalyst monitor sensor
• Engine control module
• Engine coolant temperature sensor
• Fuel rail pressure sensor
• Fuel temperature sensor
• Heated oxygen sensor
• Knock sensor
• Manifold absolute pressure sensor
• Mass air flow sensor
• Variable camshaft timing oil control solenoid
• Brake pedal position switch
• Oil temperature sensor
• Engine oil pressure sensor
• Intake air temperature sensor

Automatic transmission / transaxle

• Extension housing seal
• Transmission fluid pan, gasket and filter
• Transmission control module and main control valve body
• Transmission support insulator

Transmission / transaxle cooling

Automatic transmission / transaxle external controls

• Selector lever cable adjustment
• External controls
• Downshift paddle switch
• Selector lever assembly
• Selector lever cable and bracket
• Selector lever knob
• Upshift paddle switch

Exhaust system

• Catalytic converter
• Front muffler
• Muffler and tailpipe
• Exhaust sound enhancement vacuum pump

Fuel system - general information

• Fuel system pressure release
• Fuel tank draining
• Quick release coupling
• Spring lock couplings

Fuel tank and lines

• Fuel filter
• Fuel level sender
• Fuel pump module
• Fuel tank
• Fuel tank filler pipe

Acceleration control

Fuel system

• Accelerator pedal
• Speed control
• Speed control deactivator switch
• Speed control module
• Speed control sensor
• Speed control switch

Climate control system - general information

• Air conditioning system flushing
• Contaminated refrigerant handling
• Electronic leak detection
• Refrigerant oil adding

Air distribution and filtering

• Center registers
• Driver side register
• Passenger side register
• Pollen filter

Heating and ventilation

• Auxiliary coolant flow pump
• Blower motor
• Heater core
• Heater core and evaporator core housing

Air conditioning

• Air conditioning compressor
• Blower motor resistor
• Condenser core
• Evaporator core
• Pressure cutoff switch
• Thermostatic expansion valve

Control components

• Ambient air temperature sensor
• Defrost vent / register blend door actuator
• Footwell vent / duct blend door actuator
• In-vehicle temperature sensor
• Recirculation blend door actuator
• Sunload sensor
• Climate control module

Instrument cluster and panel illumination

• Instrument cluster
• Horn
• Instrumentation and warning systems
• Information and message center
• Warning devices

Parking aid

• Parking aid module
• Rear parking aid sensor
• Front inner parking aid sensor
• Front outer parking aid sensor

Battery and charging system

• Charging system - general information
• Battery, mounting and cables
• Generator and regulator

Information and entertainment systems

• Information and entertainment system - general
• Audio system
• Cellular phone
• Audio unit
• Amplifier
• Audio unit
• Steering wheel audio controls
• Antenna
• Speakers
• Front door speaker
• Front door tweeter speaker
• Subwoofer speaker
• Quarter panel speaker - 2-door
• Quarter panel speaker - convertible

Lighting

• Exterior lighting
• Headlamp adjustment
• Headlamps
• Front fog lamp
• Fog lamp bulb
• Rear fog and reversing lamp
• Interior lighting
• Daytime running lamps

Electrical distribution

• Module communications network
• Auxiliary junction box
• Central junction box
• Module configuration
• Wiring harnesses

Electronic feature group

• Anti-theft - active
• Anti-theft alarm horn
• Rear intrusion sensor
• Anti-theft - passive
• Remote convenience
• Navigation system
• Navigation system antenna
• Navigation system display module
• Navigation system module
• Cellular phone
• Cellular phone antenna
• Transceiver module
• Multifunction electronic modules
• Driver seat module
• Information and entertainment module
• Remote keyless entry module

Body and paint

• Front end body panels
• Air deflector
• Cowl vent screen
• Fender splash shield
• Radiator splash shield
• Body closures
• Hood alignment
• Luggage compartment lid alignment
• Liftgate alignment
• Hood
• Luggage compartment lid
• Door
• Liftgate

Interior trim and ornamentation

• Pillar trim panel
• Engine cover
• Front door trim panel
• Headliner
• Front scuff plate trim panel
• Scuff plate trim panel
• Sun visor
• Liftgate upper trim panel
• Liftgate lower trim panel
• Loadspace trim panel
• Luggage compartment lid trim panel

Exterior trim and ornamentation

• Front fender moulding
• Rear spoiler
• Rocker panel moulding
• Rear view mirrors
• Auto-dimming interior mirror
• Exterior mirror
• Exterior mirror glass
• Exterior mirror motor

Seating

• Front seat
• Front seat backrest cover
• Front seat control switch
• Front seat cushion cover
• Front seat lumbar motor
• Front seat recliner motor
• Rear seat armrest
• Rear seat backrest
• Rear seat cushion
• Front seat backrest heater mat

Rear view mirrors

• Front seat cushion heater mat
• Seat track
• Rear seat backrest

Glass, frames and mechanisms

• Door window glass adjustment
• Front door window glass
• Front door window regulator motor
• Window control switch
• Windshield glass
• Rear quarter window glass

Instrument panel and console

• Instrument panel
• Floor console
• Floor console finish panel
• Glove compartment
• Instrument panel
• Overhead console
• Instrument panel lower trim panel

Handles, locks, latches and entry systems

• Door lock cylinder cover
• Exterior door handle
• Luggage compartment lid latch actuator
• Luggage compartment lid lock cylinder
• Liftgate lock cylinder
• Liftgate latch actuator
• Radio frequency receiver
• Keyless vehicle front antenna
• Keyless vehicle center antenna
• Hood latch

Wipers and washers

• Headlamp washer jet
• Headlamp washer pump
• Rain sensor
• Windshield washer pump
• Windshield washer reservoir
• Windshield wiper motor
• Wiper pivot arm

Convertible top

Bumpers

• Front bumper
• Rear bumper

Safety belt system

• Front safety belt buckle
• Rear safety belt buckle
• Rear safety belt retractor

Supplemental restraint system

• Air bag supplemental restraint system
• Front impact severity sensor
• Driver air bag module
• Front passenger seat occupant classification sensor
• Restraints control module
• Passenger air bag module
• Side air bag module
• Rollover protection unit
• Side impact sensor

Pedestrian protection system

• Pedestrian protection module
• Pedestrian impact sensor
• Pedestrian protection latch actuator
• Pedestrian protection accelerometer
• Pedestrian protection hood actuator

Body repairs - general information

• Body repairs - corrosion protection
• Body repairs - water leaks
• Body repairs - vehicle specific information and tolerance checks
• Front end sheet metal repairs
• Front end sheet metal
• Front fender
• Front crossmember
• Fender apron panel
• Front side member
• Front wheelhouse
• Fender apron panel
• Suspension top mount
• Roof sheet metal repairs
• Side panel sheet metal repairs
• Rocker panel
• Bulkhead lower reinforcement
• Rear end sheet metal repairs
• Rear wheelhouse outer
• Rear inner wheelhouse half
• Rear outer wheelhouse half
• Rear lamp mounting panel
• Spare wheel well
• Rear side member section
• Back panel
• Rear side member closing panel
• Rear side member reinforcement panel
• Water drain panel

Uni-body, subframe and mounting system

• Front subframe
• Rear subframe
• Rear subframe front bushing
• Rear subframe rear bushing

Customers reviews