Jaguar XF (X250) 2008 thru 2009, repair e-manual

Content

General information

• Service information
• General information
• Identification codes
• Jacking and lifting
• Noise, vibration and harshness

Suspension

• Suspension system - general information
• Diagnosis and testing
• General procedures
• Front suspension
• Front shock absorber
• Front lower arm
• Rear lower arm
• Rear lower arm bushing
• Shock absorber bushing
• Front stabilizer bar
• Stabilizer bar link bushing
• Upper arm
• Front wheel bearing and wheel hub
• Wheel knuckle
• Rear suspension
• Rear stabilizer bar
• Rear wheel bearing
• Wheels and tires
• Tire low pressure sensor
• Tire pressure monitoring system
• Vehicle dynamic suspension
• Front suspension vertical accelerometer
• Rear suspension vertical accelerometer
• Ride and handling optimization

Driveline

• Driveline system - general information
• Driveshaft
• Rear drive axle / differential
• Rear drive halfshafts

Brake system

• Brake system - general information
• Front disc brake
• Brake caliper
• Brake disc shield
• Brake pads
• Rear disc brake
• Parking brake cable
• Parking brake module
• Parking brake switch
• Parking brake release actuator
• Hydraulic brake actuation
• Brake fluid reservoir
• Brake master cylinder
• Power brake actuation
• Power brake system
• Brake booster
• Brake vacuum pump
• Anti-lock control - stability assist
• Anti-lock brake system module
• Front wheel speed sensor
• Rear wheel speed sensor
• Steering wheel rotation sensor
• Yaw rate sensor and accelerometer

Steering system

• Steering system - general information
• Power steering
• Steering gear
• Power steering fluid cooler
• Power steering fluid reservoir
• Power steering pump
• Steering linkage
• Tie rod end
• Steering column
• Steering wheel
• Steering column switches
• Hazard flasher switch
• Steering column multifunction switch

Engine

• Piston inspection
• Exhaust manifold cleaning and inspection
• Cylinder head distortion
• Cylinder bore out-of-round
• Crankshaft main bearing journal clearance
• Crankshaft end play
• Connecting rod large end bore
• Connecting rod cleaning
• Camshaft surface inspection
• Camshaft lobe lift
• Camshaft end play
• Camshaft bearing journal diameter
• Camshaft bearing journal clearance
• Bearing inspection
• Engine system - general information
• Piston pin diameter
• Piston pin to bore diameter
• Piston ring end gap
• Piston ring-to-groove clearance
• Valve spring free length
• Valve stem diameter
• Camshaft front seal
• Camshaft
• Camshaft rear seal
• Crankshaft front seal
• Crankshaft pulley
• Crankshaft rear seal
• Crankshaft vibration damper
• Cylinder head
• Engine mount
• Exhaust manifold
• Flexplate
• Oil filter element
• Oil pan
• Oil pan extension
• Oil pump
• Timing belt
• Timing cover
• Valve cover

Engine cooling

• Cooling system draining, filling and bleeding
• Coolant expansion tank
• Cooling fan motor and shroud
• Coolant pump
• Radiator
• Thermostat

Fuel charging and controls

• Fuel charging and controls
• Fuel injection component cleaning
• Fuel injector
• Fuel injection pump
• Intake air shutoff throttle
• Swirl plate actuator diaphragm
• Turbocharger
• Throttle body

Accessory drive

• Accessory drive belt
• Accessory drive belt idler pulley
• Accessory drive belt tensioner
• Fuel injection pump belt
• Fuel injection pump pulley
• Supercharger belt
• Supercharger belt tensioner
• Supercharger belt idler pulley

Starting system

• Starter motor

Engine ignition

• Ignition coil-on-plug

Glow plug system

Engine emission control

• Crankcase vent oil separator
• Exhaust gas recirculation valve outlet tube
• Exhaust gas recirculation valve
• Secondary air injection control valve
• Secondary air injection control valve to exhaust manifold tube
• Secondary air injection pump

Intake air distribution and filtering

• Air cleaner
• Air cleaner element
• Charge air cooler
• Air cleaner outlet pipe
• Supercharger
• Supercharger outlet pipe

Evaporative emissions

• Evaporative emission canister
• Evaporative emission canister purge valve
• Evaporative emission canister vent solenoid

Electronic engine controls

• Camshaft position sensor
• Crankshaft position sensor
• Crankshaft position sensor ring
• Engine control module
• Engine coolant temperature (sensor)
• Engine oil pressure sensor
• Fuel rail pressure sensor
• Fuel temperature sensor
• Knock sensor
• Intake air temperature sensor
• Manifold absolute pressure sensor
• Mass air flow sensor
• Oil temperature sensor
• Variable camshaft timing oil control solenoid

Automatic transmission / transaxle

• Extension housing seal
• Transmission fluid pan, gasket and filter
• Transmission control module and main control valve body
• Transmission fluid cooler
• Transmission control switch
• Transmission control switch knob
• Emergency park position release lever
• Upshift paddle switch
• Downshift paddle switch

Exhaust system

• Catalytic converter
• Exhaust system
• Diesel particulate filter
• Diesel particulate filter differential pressure sensor
• Front muffler
• Rear muffler

Fuel system

• Fuel system - general information
• Fuel system pressure check
• Fuel system pressure release
• Fuel tank draining
• Low-pressure fuel system bleeding
• Spring lock couplings
• Quick release coupling
• Fuel tank and lines
• Fuel cooler
• Fuel filter
• Fuel tank
• Fuel pump module
• Fuel transfer unit

Speed control

• Speed control deactivator switch
• Speed control module
• Speed control sensor
• Speed control switch

Climate control system

• Heating and ventilation
• Air conditioning
• Control components
• Ambient air temperature sensor
• Blower motor
• Blower motor control module
• Center registers
• Climate control assembly
• Climate control module
• Defrost vent / register blend door actuator
• Driver side register
• Evaporator
• Floor console register
• Footwell vent / duct blend door actuator
• Heater core
• Heater core and evaporator core housing
• Instrument panel register trim panel
• In-vehicle temperature sensor
• Passenger side register
• Pollen filter
• Recirculation blend door actuator
• Sunload sensor
• Thermostatic expansion valve

Instrumentation and warning systems

• Instrument cluster
• Horn
• Horn switch
• Information and message center
• Warning devices
• Parking aid
• Front inner parking aid sensor
• Front outer parking aid sensor
• Parking aid camera
• Parking aid module
• Rear parking aid sensor

Battery and charging system

• Charging system
• Battery, mounting and cables
• Generator and regulator

Information and entertainment systems

• Speakers
• Cellular phone
• Navigation system
• Video system
• Audio unit
• Audio unit antenna amplifier
• Audio and climate control assembly
• Front door speaker
• Information and entertainment display
• Information and entertainment module
• Instrument panel speaker
• Rear door speaker
• Steering wheel audio controls
• Subwoofer amplifier
• Subwoofer speaker

Lighting

• Exterior lighting
• Approach lamp
• Headlamp assembly
• Headlamp leveling front sensor
• Headlamp leveling rear sensor
• High mounted stoplamp
• Rear fog lamp
• Rear lamp assembly
• Side turn signal lamp
• Interior lighting
• Daytime running lamps

Electrical distribution

• Module communications network
• Wiring harnesses

Electronic feature group

• Anti-theft
• Navigation system
• Cellular phone
• Multifunction electronic modules

Body and paint

• Front end body panels
• Air deflector
• Cowl vent screen
• Engine rear undershield
• Fender splash shield
• Radiator splash shield
• Secondary bulkhead center panel
• Secondary bulkhead panel
• Body closures
• Front door
• Fuel filler door
• Fuel filler door assembly
• Luggage compartment lid
• Rear door
• Interior trim and ornamentation
• Exterior trim and ornamentation

Rear view mirrors

• Exterior mirror
• Exterior mirror cover
• Exterior mirror glass
• Exterior mirror motor
• Interior rear view mirror

Seating

• Front seat backrest
• Front seat backrest cover
• Front seat cushion cover
• Front seat track motor
• Memory seat position switch
• Seat base
• Rear seat backrest cover
• Rear seat cushion
• Front seat height adjustment motor
• Front seat control switch
• Rear seat bolster

Door window regulator motor

• Driver door window control switch
• Front door window glass
• Front door window regulator and motor
• Passenger door window control switch
• Rear door fixed window glass
• Rear door window glass
• Rear door window regulator and motor
• Rear window glass
• Windshield glass
• Glass, frames and mechanismss

Instrument panel and console

• Floor console
• Floor console cup holder
• Floor console double cup holder
• Floor console side trim panel
• Glove compartment
• Instrument panel console
• Instrument panel lower trim panel
• Overhead console

Handles, locks, latches and entry systems

• Exterior front door handle
• Exterior luggage compartment lid release switch
• Exterior rear door handle
• Front door latch
• Front door lock cylinder
• Interior front door handle
• Luggage compartment lid latch actuator
• Luggage compartment lid lock cylinder
• Rear door latchc

Wipers and washers

• Headlamp washer jet
• Headlamp washer pump
• Rain sensor
• Windshield washer reservoir
• Windshield wiper motor
• Windshield washer pump

Roof opening panel

• Roof opening panel front drain hose
• Roof opening panel frame
• Roof opening panel glass
• Roof opening panel motor
• Roof opening panel rear drain hose
• Roof opening panel weatherstrip

Bumpers

• Front bumper cover
• Front bumper cover insert
• Rear bumper cover
• Rear bumper

Safety belt system

• Front safety belt buckle
• Front safety belt retractor
• Rear center safety belt retractor
• Rear safety belt buckle
• Rear safety belt retractor
• Safety belt shoulder height adjuster

Supplemental restraint system

• Pillar side impact sensor
• Clockspring
• Pillar side impact sensor
• Crash sensor
• Driver air bag module
• Front door side impact sensor
• Occupant classification sensor
• Passenger air bag module
• Restraints control module

Pedestrian protection system

• Pedestrian impact sensor
• Pedestrian protection hood actuator
• Pedestrian protection module

Body repairs

• Corrosion protection
• Water leaks
• Vehicle specific information and tolerance checks
• Front end sheet metal repairs
• Roof sheet metal repairs
• Side panel sheet metal repairs
• Rear end sheet metal repairs

Frame and mounting

• Uni-body, subframe and mounting system

Customers reviews