Infiniti I35 (A33) 2002 thru 2004, repair e-manual 5 parts

Content

General information

• Precaution
• How to use this manual
• How to read wiring diagrams
• How to check terminal
• How to perform efficient diagnosis for an electrical incident
• How to follow trouble diagnoses
• Consult-II checking system
• Identification information
• Lifting points and tow truck towing
• Recommended chemical products and sealants
• Tightening torque of standard bolts
• Sae J1930 terminology list

Maintenance

• Precautions
• Preparation
• General maintenance
• Periodic maintenance
• Recommended fluids and lubricants
• Engine maintenance
• Chassis and body maintenance
• Service data and specifications

Engine mechanical

• Precautions
• Preparation
• Noise, vibration and harshness (NVH) troubleshooting
• Outer component parts
• Measurement of compression pressure
• Oil pan
• Timing chain
• Oil seal
• Cylinder head
• Engine assembly
• Cylinder block
• Service data and specifications

Engine lubrication and cooling systems

• Engine lubrication system
• Engine cooling system

Engine control system

• Precautions and preparation
• Engine and emission control overall system
• Engine and emission basic control system description
• Basic service procedure
• On board diagnostic system description
• Trouble diagnosis
• Variable induction air control system
• Ignition signal
• Injector
• Start signal
• Fuel pump
• Electronic controlled engine mount
• Refrigerant pressure sensor
• Electrical load signal
• Data link connectors
• Service data and specifications

Accelerator control, fuel and exhaust systems

• Preparation
• Accelerator control system
• Fuel system
• Exhaust system

Automatic transaxle

• Precautions and preparation
• Trouble diagnoses
• Overall system
• On board diagnostic system description
• A/T shift lock system
• Shift control system
• On-vehicle service
• Removal and installation
• Overhaul
• Disassembly
• Repair for component parts
• Assembly
• Service data and specifications

Front and rear axle

• Front axle
• Rear axle

Front and rear suspension

• Front suspension
• Rear suspension

Brake system

• Precautions and preparation
• Noise, vibration and harshness (NVH) troubleshooting
• On-vehicle service
• Brake hydraulic line
• Brake pedal and bracket
• Master cylinder
• Brake booster
• Vacuum hose
• Front disc brake
• Rear disc brake
• Parking brake control
• CAN communication
• Trouble diagnoses
• Trouble diagnoses for symptoms
• VDC / TCS / ABS control unit
• VDC / TCS / ABS actuator and relay box
• YAW rate / side G sensor
• VDC off switch
• Service data and specifications

Steering system

• Precautions and preparation
• Noise, vibration and harshness (NVH) troubleshooting
• On-vehicle service
• Steering wheel and steering column
• Power steering gear and linkage
• Power steering oil pump
• Service data and specifications

Restraint system

• Seat belts
• Supplemental restraint system

Body and trim

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Clip and fastener
• Body front end
• Body rear end and opener
• Door
• Instrument panel assembly
• Trim
• Exterior
• Seat
• Sunroof
• Windshield and windows
• Door mirror
• Body (alignment)

Heater and air conditioner

• Precautions and preparation
• Description
• Trouble diagnoses
• System description
• Service procedures
• Service data and specifications

Starting and charging system

• Precautions
• Preparation
• Battery
• Starting system
• Charging system
• Service data and specifications

Electrical system

• Precautions
• Harness connector
• Standardized relay
• Power supply routing
• Ground
• Combination switch
• Steering switch
• Heated steering
• Headlamp
• Parking, license and tail lamps
• Stop lamp
• Back-up lamp
• Front fog lamp
• Turn signal and hazard warning lamps
• Cornering lamp
• Illumination
• Interior, step, spot, vanity mirror and trunk room lamps
• Meters and gauges
• Board computer
• Compass
• Warning lamps
• A/T indicator
• Warning chime
• Front wiper and washer
• Horn
• Cigarette lighter
• Rear window defogger
• Audio
• Audio antenna
• Power sunroof
• Door mirror
• Auto anti-dazzling inside mirror
• Trunk lid and fuel filler lid opener
• Telephone
• Automatic drive positioner
• Power seat
• Heated seat
• Rear sunshade
• Automatic speed control device
• Power window
• Power door lock
• Remote keyless entry system
• Vehicle security (theft warning) system
• Smart entrance control unit
• Homelink universal transceiver
• Infiniti vehicle immobilizer system - NATS
• Navigation system
• CAN communication
• Electrical units location
• Harness layout
• Bulb specifications
• Wiring diagram codes

Customers reviews