Infiniti G20 (P11) 1998 thru 2002, repair e-manual

Content

General information

• Precautions
• How to use this manual
• How to read wiring diagrams
• How to check terminal
• How to perform efficient diagnosis for an electrical incident
• How to follow trouble diagnoses
• Consult-II checking system
• Identification information
• Lifting points and tow truck towing
• Tightening torque of standard bolts
• SAE J1930 terminology list

Maintenance

• Precautions
• Preparation
• General maintenance
• Periodic maintenance
• Recommended fluids and lubricants
• Engine maintenance
• Chassis and body maintenance
• Service data and specifications

Engine mechanical

• Precautions
• Preparation
• Noise, vibration and harshness troubleshooting
• Outer component parts
• Measurement of compression pressure
• Oil pan
• Timing chain
• Oil seal
• Cylinder head
• Engine assembly
• Cylinder block
• Service data and specifications

Engine lubrication and cooling systems

• Engine lubrication system
• Oil pump
• Oil filter
• Engine cooling system
• Water pump
• Thermostat
• Water outlet
• Radiator

Engine control system

• Trouble diagnosis - index
• Precautions
• Preparation
• Fuel tank
• Engine and emission control overall system
• Engine and emission basic control system description
• Basic service procedure
• On board diagnostic system description
• Trouble diagnosis - introduction
• Ignition signal
• Njector
• Start signal
• Fuel pump
• Power steering oil pressure switch
• Refrigerant pressure sensor
• Electrical load signal
• Mil and data link connectors
• Service data and specifications

Accelerator control, fuel and exhaust systems

• Preparation
• Accelerator control system
• Fuel system
• Exhaust system

Clutch

• Precautions
• Preparation
• Noise, vibration and harshness troubleshooting
• Clutch system
• Clutch master cylinder
• Clutch damper
• Operating cylinder
• Piping
• Clutch release mechanism
• Clutch disc, clutch cover and flywheel
• Service data and specifications

Manual transaxle

• Preparation
• Noise, vibration and harshness troubleshooting
• Description
• On-vehicle service
• Removal and installation
• Overhaul
• Disassembly
• Repair for component parts
• Assembly
• Service data and specifications

Automatic transaxle

• Trouble diagnosis - index
• Precautions
• Preparation
• Overall system
• On board diagnostic
• Trouble diagnosis
• A/T shift lock system
• Key interlock cable
• On-vehicle service
• Removal and installation
• Overhaul
• Disassembly
• Repair for component parts
• Assembly
• Service data and specifications

Front and rear axle

• Front axle
• Wheel hub and knuckle
• Drive shaft
• Rear axle

Front and rear suspension

• Front suspension
• Coil spring and shock absorber
• Third link and upper link
• Stabilizer bar
• Rear suspension

Brake system

• Precautions
• Preparation
• Noise, vibration and harshness troubleshooting
• On-vehicle service
• Brake hydraulic line
• Dual proportioning valve
• Brake pedal and bracket
• Master cylinder
• Brake booster
• Vacuum hose
• Front disc brake
• Rear disc brake
• Parking brake control
• ABS

Steering system

• Precautions
• Preparation
• Noise, vibration and harshness troubleshooting
• On-vehicle service
• Steering wheel and steering column
• Power steering gear and linkage
• Power steering oil pump
• Service data and specifications

Restraint system

• Seat belts
• Supplemental restraint system

Body and trim

• Precautions
• Preparation
• Squeak and rattle trouble diagnoses
• Clip and fastener
• Body front end
• Body rear end and opener
• Front door
• Rear door
• Instrument panel assembly
• Side and floor trim
• Door trim
• Roof trim
• Trunk room trim
• Exterior
• Front seat
• Rear seat
• Sunroof
• Windshield and windows
• Door mirror
• Body (alignment)

Heater and air conditioner

• Precautions
• Preparation
• Description
• Trouble diagnoses
• Service procedure

Starting and charging system

• Precautions
• Preparation
• Battery
• Starting system
• Charging system
• Service data and specifications

Electrical system

• Precautions
• Harness connector
• Standardized relay
• Power supply routing
• Ground
• Combination switch
• Steering switch
• Headlamp
• Parking, license and tail lamps
• Stop lamp
• Back-up lamp
• Front fog lamp
• Turn signal and hazard warning lamps
• Illumination
• Interior room lamp
• Vanity mirror and trunk room lamps
• Meters and gauges
• A/T indicator
• Warning chime
• Front wiper and washer
• Horn
• Cigarette lighter
• Rear window defogger
• Audio
• Audio antenna
• Trunk lid and fuel filler lid opener
• Power sunroof
• Door mirror
• Power seat
• Heated seat
• Automatic speed control device
• Power window
• Power door lock
• Multi-remote control system
• Vehicle security (theft warning) system
• Smart entrance control unit
• IVIS (Infiniti vehicle immobilizer system - NATS)
• Integrated homelink transmitter
• Electrical units location
• Harness layout
• Bulb specifications
• Wiring diagram codes

Index

Customers reviews