Hyundai Tiburon since 2003, repair e-manual

Content

Introduction

• Vehicle identification number
• Identification number locations / decription
• Engine identification number
• Transmission identification number
• Warning/caution label locations
• Emission control label
• Lift and support point
• Towing
• Tightening torque table of standard parts
• Recommended lubricants
• Lubricants capacities
• Selection of engine oil
• General service information
• Special tools
• Recommended sae viscosity grades
• Removal of parts

Electrical system

• Rubber parts and tubes
• Servicing the electrical system
• Precautions for catalytic converter
• Battery test
• Starter
• Charging system
• Troubleshooting
• Specification

Auto cruise control system

• Tightening torque
• On-vehicle inspection
• Spark
• Circuit diagram
• Drive belt
• Alternator belt
• Start
• Starter
• Auto cancellation
• Components location
• Brake switch
• Cruise control
• Actuator cable
• Radiator cap
• Specific gravity
• Oil seal (camshaft front)
• HLA (hydraulic lash adjuster)
• Timing chain
• Valve guides
• Valve
• Valve spring
• Piston rings<
• Measuring oil clearance
• Oil seal
• Cylinder block
• Boring cylinder
• Engine mounting
• Transaxle mounting
• Front roll stopper
• Rear roll stopper

Cooling system

• Inlet control
• Flow chart
• Cooling system components
• Coolant temperature sensor
• Oil pump
• Relief plunger and spring
• Oil filter bracket
• Oil pressure switch

Emission control

• Air cleaner
• Intake manifold
• Surge tank and intake manifold
• Exhaust manifold
• Muffler
• Front exhaust pipe
• Emission control system
• Vacuum hoses
• Emission control system
• Crankcase emission control system
• Positive crankcase ventilation
• Evaporative emission control system
• Air filter
• Purge control solenoid valve (PCSV)
• EVAP canister purge solenoid valve

Fuel system

• Vacuum hose
• Fuel tank pressure sensor (FTPS)
• Fuel filler cap operation
• Fuel system special tools
• Multiport fuel injection (MFI)
• Fuel injection control
• Ignition timing
• Major sensor reference wave-forms

Suspension

• Wheel and tire diagnosis
• Front strut
• Front lower arm
• Ball joint and dust cover
• Lower arm bushing
• Front lower arm
• Front stabilizer bar
• Rear strut
• Rear suspension arm
• Rear suspension arm bushing
• Rear stabilizer bar
• Tires /wheels

Driveshaft and axle

• Front driveshaft
• Center bearing and inner shaft components
• Front hub / axle
• Rear hub / carrier

Brake system

• Brake system
• Brake pedal and brake switch
• Pedal height
• Brake switch clearance
• Pedal free play
• Parking brake
• Front / rear disc brake
• Brake booster
• Master cylinder
• Proportioning valve
• Brake line
• Brake pedal
• Front disc brake
• Brake pad
• Front disc brake
• Rear disc brake
• Parking brake
• ABS
• Traction control system (TCS)
• Full traction control system (FTCS)
• EBD (electronic brake-force distribution)
• Wheel speed sensor

Manual transaxle

• Transaxle gear oil
• Drive shaft oil seal
• Manual transaxle shift control
• Automatic transaxle shift control
• Automatic transaxle fluid
• Transaxle range switch continuity
• Solenoid valve

Clutch

• Clutch cover and dinode
• Clutch disc
• Clutch master cylinder
• Clutch pedal

Steering

• Steering system lubricants
• Power steering gear box
• Tie rod swing
• Power steering hoses
• Pressure hose and tube
• Power steering oil pump

Heating,ventilation, air conditioning precautions

• Refrigerant
• System evacuation
• Compressor
• Receiver
• Refrigerant line component
• Triple pressure switch
• In-car sensor
• Ambient sensor
• A.Q.S (air quality sensor)
• Heater unit component
• Temperature control actuator
• Mode control actuator connector
• Blower unit
• Blower motor
• Blower relay
• Power transistor
• Intake actuator
• Control panel
• Manual controller
• Intake and AQS

Restraint

• SRSCM (supplemental restraints system control module)
• Satellite sensor
• Supplemental restraint system control module
• Airbag module
• Passenger airbag (PAB)
• Side airbag (SAB)
• Satellite sensor
• Seat belt pretensioner

Body

• Fender garnish
• Hood hinge/latch
• Door
• Exterior mirror
• Sun roof
• Interior console
• Crash pad
• Interior trim
• Cowl side trim
• Luggage board
• Head lining
• Windshield glass
• Tailgate glass
• Quarter glass
• Bumper
• Front seat belt
• Rear seat belt
• Body electrical
• Audio unit
• Tape head and capstan
• Multifunction switch
• Horn
• Keyless entry
• Body control module
• Relay box
• Instrument cluster
• Windshield wiper / washer
• Lighting system
• Immobilizer system

Customers reviews