Our books can be purchased by cards єPidtrimka!

Content

Your car Toyota Corolla

  • Introduction
  • Safety first!
  • Troubleshooting an emergency
  • If the engine does not start and the starter motor does not scroll
  • If the engine does not start and the starter motor rotates normally
  • Starting the engine from an additional power source
  • Wheel replacement
  • Leak detection
  • Towing
  • Weekly checks
  • Checks under the hood of the car
  • Engine oil level
  • Coolant level
  • Brake fluid level
  • Washer fluid level
  • Tire condition and air pressure
  • Windshield wipers
  • Battery
  • Electrical systems
  • Working fluids and lubricants
  • Tire pressure

Instruction manual

  • General view of the dashboard
  • Signal indicators on the dashboard
  • General view of the instrument panel
  • Sensors and pointers
  • Operation of instruments and controls
  • Fuses

Regular maintenance - petrol engines

  • General information
  • Regular maintenance
  • Replacement of engine oil and filter
  • Checking hoses and leaks of working fluids
  • Checking the drive shaft anther
  • Lubrication of awnings and locks
  • Replacement and check of a level of a working liquid of an automatic transmission
  • Checking and replacing the auxiliary drive belt
  • Replacement and inspection of the air filter
  • Checking and adjusting the parking brake
  • Checking brake pads
  • Checking the suspension and exhaust system
  • Checking the steering and suspension system
  • Checking and adjusting the clutch pedal
  • Checking the particle filter
  • Road test
  • Checking the parking brake pads
  • Replacing the batteries of the control panel
  • Brake fluid replacement
  • Replacing coolant
  • Replacement and check of oils level
  • Replacement of spark plugs
  • Checking and adjusting the valve clearance

Regular maintenance - diesel engines

  • General information
  • Regular maintenance
  • Replacement of engine oil and filter
  • Checking hoses and leaks of working fluids
  • Checking the drive shaft anther
  • Lubrication of awnings and locks
  • Replacement and check of oils level
  • Checking and replacing the auxiliary drive belt
  • Replacement and inspection of the air filter
  • Checking and adjusting the parking brake
  • Checking brake pads
  • Check of suspensions and pipelines of system of release of the fulfilled gases
  • Checking the steering and suspension system
  • Checking and adjusting the clutch pedal
  • Checking the particle filter
  • Road test
  • Replacing the fuel filter
  • Checking the parking brake pads
  • Replacing the batteries of the control panel
  • Brake fluid replacement
  • Replacing coolant
  • Checking and replacing the hose and valve of the crankcase ventilation system
  • Checking and adjusting the valve clearance
  • Replacing the timing belt

Repair procedures without removing the engine from the engine compartment - gasoline engines

  • General information
  • Compression check
  • The top dead center of the piston of the first cylinder
  • Cylinder head cover - removal and installation
  • Chain of timing and sprocket drive -replacement, inspection and installation
  • Variable timing components (VVT-i) - removal, inspection and installation
  • Right crankshaft oil seal - replacement
  • Camshafts and pushers - removal, inspection and installation
  • Cylinder head - removal and installation
  • Oil pan - removal and installation
  • Oil pump - removal, inspection and installation
  • Engine oil pressure sensor - replacement
  • Flywheel - removal, inspection and installation
  • Crankshaft oil seal - replacement
  • Engine / gearbox mountings - check and replace

Repair procedures without removing the engine from the engine compartment - diesel engines

  • General information
  • Procedures that can be performed without removing the engine from the engine compartment
  • The top dead center of the piston of the first cylinder
  • Cylinder head cover - removal and installation
  • Intake manifold - removal and installation
  • Exhaust manifold - removal and installation
  • Timing belt and sprockets - removal, inspection and installation
  • Right crankshaft oil seal - replacement
  • Right camshaft seal - replacement
  • Camshafts and pushers - removal and installation
  • Cylinder head - removal and installation
  • Oil pan - removal and installation
  • The upper shell of the oil pump and the pallet - removal, inspection and installation
  • Flywheel - removal and installation
  • Crankshaft oil seal - replacement
  • Engine supports - checking and replacing

Removing the engine from the engine compartment and the overhaul procedure

  • General information
  • Major engine repairs - general information
  • Engine removal - methods and precautions
  • Engine - removal and installation
  • Alternative engine replacement
  • Engine overhauling - sequence of disassembly
  • Cylinder head - disassembly
  • Cylinder head and valves - cleaning and checking
  • Valves - maintenance
  • Cylinder head - assembly
  • Piston / connecting rod assembly - removal
  • Crankshaft removal
  • Cylinder block - cleaning
  • Cylinder block - check
  • Piston / connecting rod assembly - check
  • Crankshaft check
  • The main bearing and the lower end of the connecting rod - check
  • Engine overhaul - assembly sequence
  • Piston rings - installation
  • Crankshaft - installation
  • Pistons / connecting rods - installation
  • The engine is the beginning of traffic after major repairs

Cooling system, heater and air conditioning

  • General information
  • Coolant / antifreeze - general information
  • Thermostat - check and replace
  • Engine cooling fan and relay - check and replace
  • Radiator - removal and installation
  • Water pump - check
  • Water pump - removal and installation
  • Coolant temperature transmitter - check and replace
  • Motor fan resistor and fan motor - replacement
  • Heatsink radiator - removal and installation
  • Control unit for air conditioning and heater - removal and installation
  • Air conditioning and heating system - check and maintenance
  • Receiver / dehumidifier of air conditioning system - removing and installing
  • Air conditioning compressor - removal and installation
  • Air conditioning condenser - removing and installing
  • Evaporator of air conditioning system - removal and installation
  • Air conditioning sensors - replacement

Power system and exhaust system - gasoline engines

  • General information
  • Fuel injection system - pressure relief
  • Fuel pump - removal and installation
  • Fuel level transmitter - check and replace
  • Fuel lines and fittings - check and replace
  • Fuel tank - removal and installation
  • Fuel tank cleaning and repair - general information
  • Air filter assembly - removing and installing
  • Throttle cable - removal, installation and adjustment
  • Fuel injection system - general information
  • Fuel injection system - check and adjustment
  • Fuel injection system - component testing and replacement
  • Intake manifold - removal and installation
  • Exhaust manifold - removal and installation
  • Exhaust system - removal and installation

Power system and exhaust system - diesel engines

  • General information
  • Fuel lines and fittings - general information
  • Fuel level transmitter - removing and installing
  • Fuel tank - removal and installation
  • Cleaning and repair of the fuel tank
  • Air filter and intake system - removing and installing
  • Fuel filter - removal, replacement and installation
  • High-pressure fuel pump (injection pump) - check, removal and installation
  • Common rail system for high pressure - removal and installation
  • High pressure fuel lines - removal and installation
  • Nozzles - check, remove and install
  • On-board diagnostic system and DTCs
  • Electrical components of the fuel injection system - check, remove and install
  • Turbocharger - check, removal and installation
  • Intercooler - removing and installing
  • Exhaust system - removal and installation

Control systems for harmful emissions - gasoline engines

  • General information
  • Fuel vapor recovery system (EVAP)
  • System of forced ventilation of crankcase (PCV)
  • Catalytic converter

Emission control systems - diesel engines

  • General information
  • Crankcase ventilation system - general information
  • Exhaust gas recirculation system - checking, removing and installing

Starting and recharging systems

  • General information
  • Battery - check and charge
  • Battery - removal and installation
  • Recharging system - general information and precautions
  • Charge system - check
  • Generator - removal and installation
  • Alternator regulator / brush holder - replacement
  • Generator - check and overhaul
  • Start-up system - general information and precautions
  • Starter - check in the car
  • Starter - removal and installation
  • Glow plug system (diesel engines) - general information
  • Glow plugs (diesel engines) - check and replace

Ignition system - petrol engines

  • General information
  • Ignition coil - replacement
  • Detonation sensor - removal, inspection and installation

Clutch

  • General information
  • Hydraulic clutch system - bleeding pressure
  • Clutch components - removal, inspection and installation
  • Clutch release bearing and lever - removal, inspection and replacement
  • Clutch master cylinder - removal, overhaul and installation
  • Clutch slave cylinder - removal, overhaul and installation
  • Clutch pedal position sensor - check and replace

Manual transmission

  • General information
  • Gear shift cables - removing and installing
  • Gear lever - removal and installation
  • Back-up light switch - check and replace
  • Manual gearbox - removing and installing
  • Major overhaul of a manual transmission - general information
  • Oil seals - replacement

Automatic transmission

  • General information
  • Diagnostics - general information
  • Replacing the gland
  • Switching cable - removal, installation and adjustment
  • System for locking the selector lever in P or N mode - removal, installation and adjustment
  • Transmission supports - check and replace
  • Automatic gearbox - removal and installation

Power shafts

  • Drive shafts - general information
  • Drive shafts - removal and installation
  • Replacement of an anther of a power shaft and Shrus check

Brake system

  • General information
  • Hydraulic system - air removal
  • Hydraulic connections and hoses
  • Front brake pads are replacement
  • Rear brake pads - replacement
  • Front disc brake - checking, removing and installing
  • Rear disc brake - removal, inspection and installation
  • Front brake caliper - removal, overhaul and installation
  • Rear brake caliper - removal, overhaul and installation
  • Brake shoes - replacement
  • Master brake cylinder - removal, overhaul and installation
  • Brake pedal - removal and installation
  • Vacuum brake booster - checking, removing and installing
  • The check valve of the vacuum amplifier of brakes - removal, check and installation
  • Parking brake - adjustment
  • Parking brake lever - removal and installation
  • Parking brake cables - removal and installation
  • Brake light switch - removal, installation and adjustment
  • Vacuum pump (diesel engines) - check, removal and installation
  • Anti-lock braking system (ABS) - general information
  • Anti-lock components (ABS) - removal and installation

Steering and suspension

  • General information
  • The front suspension bracket assembly - removal, inspection and installation
  • Rack / spring assembly - replacement
  • Stabilizers of lateral stability and the plug (forward) - removal and installation
  • Suspension lever - removal, inspection and installation
  • Ball bearings - replacement
  • Hub carrier and hub assembly (front) - removal and installation
  • Hub and bearing assembly (front) - removing and installing
  • Stabilizer of transverse stability (rear) - removal and installation
  • Rear suspension bracket assembly - removal, inspection and installation
  • Stabilizer bar for lateral stability - removal and installation
  • Bearing and hub assembly (rear) - removal and installation
  • Rear axle - removal and installation
  • Steering system - general information
  • Steering wheel - removal and installation
  • The ends of the tie rod - removal and installation
  • Anthers of the steering rack - replacement
  • Steering rail - removal and installation
  • Steering column and servo - removal and installation
  • Wheels and tires - general information
  • Wheel alignment - general information

Body structure and components

  • General information
  • Maintenance - body and frame
  • Maintenance - upholstery and rugs
  • Elimination of minor body damage - repairs
  • Elimination of serious damage to the body - repair
  • Front bumper - removal and installation
  • Rear bumper - removal and installation
  • Hood - removal, installation and adjustment
  • A cable of blocking and opening of a cowl - removal and installation
  • Hood lock - removal and installation
  • Radiator grille - removal and installation
  • Door - removal, installation and adjustment
  • Internal door trim panel - Removing and installing
  • Door handle and lock components - removal and installation
  • Door window and window lift - removal and installation
  • Luggage compartment lid and lock components - removal and installation
  • The luggage compartment door, the components of the lock and the support pillars - removal and installation
  • Components of the central lock - removal and installation
  • Components of electric glass lifts - removal and installation
  • Mirrors and their components - removal and installation
  • Windscreen, fixed glass, rear window / tailgate window - general information
  • Hatch - general information and servo replacement
  • External components of the body - removal and installation
  • Seats - removal and installation
  • Seat belt pretensioner mechanism - general information
  • Components of seat belts - removal and installation
  • Internal lining - removal and installation
  • Central console - removal and installation
  • Complete trim panels - removal and installation

Electrical equipment and electrical systems

  • General information
  • Detection of malfunctions in the electrical system - general information
  • Fuses and relays - general information
  • Switches - removal and installation
  • Dashboard - removal and installation
  • The control unit of direction indicators / light alarm - replacement
  • Lamps (external lighting) - replacement
  • Lamps (interior lighting) - replacement
  • External headlamps - removal and installation
  • Headlamps height - check and adjustment
  • Servo drive for headlights - removal and installation
  • Acoustic signal - replacement
  • Washer system components - removal and installation
  • Wiper arm - removal and installation
  • Servo and windshield wiper retractor - removing and installing
  • Rear window wiper motor - removing and installing
  • Audio system - removal and installation
  • Speakers - removal and installation
  • Passive safety system - general information and precautions
  • Airbag system - component replacement
  • Electrical diagrams - general information

Applications

  • Overall dimensions and weight
  • Fuel consumption
  • Vehicle identification numbers
  • General repair procedures
  • Lifting the car with a jack and the point of the pillars
  • Tools and devices
  • Technical condition check
  • Troubleshooting
  • Glossary
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
(10)

Replacement and inspection of the Toyota Corolla air filter since 2001

Typically, users of our site find this page for the following queries:
climate control Toyota Corolla, ventilation system Toyota Corolla, air-conditioning system Toyota Corolla, heating system Toyota Corolla

Sorry, the article is only available in Russian.

To read the article, you need to change the language on the site.