Massey Ferguson 8210 / 8220 / 8220 Xtra / 8240 / 8240 Xtra / 8250 / 8250 Xtra tractor, repair e-manual

Content

Introduction

• Reading the manual
• General specifications
• Safety instructions
• Practical advice
• Instructions for putting the tractor in service
• Conversion tables
• Locking compounds and sealants
• Tightening torques

Splitting the tractor

• Splitting the tractor between front frame / engine
• Splitting the tractor between engine / gearbox
• Splitting the tractor between gearbox / intermediate housing
• Splitting the tractor between intermediate housing / centre housing
• Splitting the tractor between pto housing / centre housing
• Chassis reinforcements
• Rear wheels / hubs

Engine

• General
• Flywheel and dampers
• Spacer
• Spacer - power shuttle

Clutch

• Pressure loaded clutch

Gearbox

• General - operation gearbox with mechanical reverse shuttle
• General - operation gearbox with power shuttle
• Input unit with mechanical reverse shuttle
• Input unit with power shuttle
• Dynashift with mechanical reverse shuttle
• Dynashift with power shuttle
• Mechanical reverse shuttle
• Power shuttle
• Selector cover - gearbox with mechanical reverse shuttle
• Selector cover - gearbox with power shuttle
• Selector cover optimised hare / tortoise function - gearbox with power shuttle
• Selector rails - gearbox with mechanical reverse shuttle
• Selector rails - gearbox with power
• Output shaft
• Mainshaft - gearbox with mechanical reverse shuttle
• Mainshaft - gearbox with power shuttle
• Layshaft
• Full powershift gearbox - general
• Full powershift gearbox - transmission hydraulic circuit
• Full powershift gearbox - transmission / repair
• Creeper unit

Rear axle

• Description
• Standard trumpet housings
• Trumpet housings with sealed compartment
• Trumpet housings with composite drive unit
• Trumpet housings with double drive unit
• Handbrake unit and control link
• Differential with standard bevel gear and hydromechanical lock
• Differential with standard bevel gear and multidisc lock
• Differential with hypoid bevel gear and multidisc lock
• Brake pistons and seals
• Park lock
• Lift cylinder supports
• Creeper unit
• Brackets and automatic hook
• Rear hitch mechanism

Power take off

• Presentation of the power take-off
• Drive pinions - bearings - layshaft
• Removable shaft
• Shiftable pto shaft
• 1000 RPM power take-off shaft
• Clutch and brake

Front axle

• Generality - carraro front axle
• Dana final drive units
• ZF final drive units
• Carraro final drive units
• Dana differential
• ZF differential
• Carraro differential
• 2 WD front axle
• Steering column
• Bearings and transmission shafts (dana front axle)
• Bearings and transmission shafts (ZF front axle)
• Bearings and transmission shafts (carraro front axle)
• 4WD clutch
• Carraro suspension
• Carraro troubleshooting

Hydraulics

• Description of the 110 L/MIN circuit
• Description of the 150 L/MIN circuit
• Priority blocks with trailer braking
• Priority blocks without trailer braking
• Auxiliary spool valves
• Lift control spool valve
• Hydrostatic steering for 2WD and 4WD front axles - AG155H / AG200H
• Hydrostatic steering for 4WD front axles - APL5052
• Right-hand cover 110 L/MIN load sensing
• 150 L/MIN right-hand cover
• Left-hand cover 110 L/MIN and 150 L/MIN load sensing
• Brake and clutch master cylinders circuit and bleeding
• Clutch control valve
• Power shuttle control unit
• Hydraulic control unit - suspended front axle
• Dynashift control
• Oil decontamination
• Hydraulic tests

Electrical equipment

• Rists electrical equipment
• Deutsch electrical equipment

Electronics

• Autotronic 2 - description
• Autotronic 2 - checking without tester
• Autotronic 3 - description
• DCC / TC - description
• DCC / TC - Calibration
• DCC / TC - error codes
• Electronic linkage - description - tractor with cab
• Electronic linkage - autodiagnostics - tractor with cab
• Datatronic 2 - description
• Datatronic 2 - front dual control
• Datatronic 2 - dual control for semimounted implement
• Datatronic 2 - tic for semimounted implement
• Wintest - general
• Autotronic 2 with wintest
• Autotronic 3 with wintest
• TC / DCC with wintest
• Electronic linkage with wintest
• Datatronic with wintest
• Joystick with wintest
• Autotronic 3 to kit autotronic
• Kit autotronic to autotronic 3
• Carraro front axle
• SMS system - description

Service tools

Customers reviews