Toyota Yaris since 2007, repair e-manual

Content

Introduction

• How to use this manual
• Identification information
• Repair instruction
• Vehicle lift and support locations
• Customize parameters
• How to troubleshoot ECU electronic circuit inspection
• Electronic circuit inspection procedure
• Terms
• Glossary of SAE и Toyota terms

Air conditioning

• Refrigerant
• Refrigerant line
• Air conditioning unit
• Blower unit
• Blower motor
• Blower resistor
• Compressor and pulley
• Ambient temperature sensor
• Air conditioning pressure sensor
• Heater blower motor relay
• Air conditioning panel
• Air conditioning amplifier

Audio / visual

• Radio receiver
• Radio antenna cord
• Amplifier antenna
• Stereo jack adapter
• Window glass antenna wire
• Front speaker
• Rear speaker

Axle

• Front axle hub bolt
• Front axle hub
• Rear axle hub bolt
• Rear axle hub and bearing

Brake

• Brake fluid
• Parking brake
• Brake brake pedal support
• Brake master cylinder
• Brake brake booster
• Front brake
• Front brake flexible hose
• Brake rear drum brake
• Rear brake flexible hose
• Proportioning valve

Brake control

• Anti-lock brake system
• Brake actuator
• Front speed sensor
• Control skid control sensor

C50 manual transaxle

• Manual transaxle oil
• Differential oil seal
• Floor shift lever
• Transmission control cable
• Manual transaxle unit
• Input shaft
• Output shaft
• Shift and select lever shaft
• Differential case

Charging

• Generator

Clutch

• Clutch pedal
• Clutch master cylinder
• Clutch release cylinder
• Clutch unit
• Clutch start switch

Cooling system

• Cooling fan system
• Coolant
• Water pump
• Thermostat
• Cooling fan relay
• Integration relay
• Cooling fan resistor
• Radiator

Cruise control

• Cruise control main switch
• Clutch switch

Drive shaft

• Front drive shaft

Emission control

• Canister
• Vacuum switching valve
• Ventilation valve
• Air fuel ratio sensor
• Heated oxygen sensor
• Fuel tank cap

Engine control

• SFI system
• Mass air flow meter
• Camshaft timing oil control valve
• Camshaft position sensor
• Engine coolant temperature sensor
• Throttle body
• Knock sensor
• Integration relay
• Accelerator pedal

Engine mechanical

• Engine immobilizer
• Drive belt
• Valve clearance
• Timing chain
• Camshaft
• Cylinder head
• Engine unit
• Starting system

Exhaust

• Exhaust pipe

Exterior

• Door lock
• Bumper
• Name plate
• Spoiler
• Front door belt moulding
• Rear door belt moulding
• Front pillar upper cover
• Roof drip side finish moulding
• Side mudguard
• Front door window frame moulding
• Luggage compartment door garnish
• Black out tape
• Horn
• Windshield / windowglass
• Wiper and washer

Fuel system

• Fuel injector
• Fuel fuel pump
• Fuel tank

Ignition system

• Ignition coil

Interior

• Instrument panel
• Roof headlining
• Lighting
• Mirror
• Seat
• Seat belt
• Theft deterrent system

Lubrication

• Oil filter
• Oil pump

Maintenance

• Outside vehicle
• Inside vehicle
• Under hood
• Engine
• Brake
• Chassis
• Body

Power steering

• Electronic power steering system
• Calibration
• Power steering gear
• Power steering ECU
• Steering column

Preparation

Service specifications

Suspension system

• Wheel alignment
• Front shock absorber with coil spring
• Front lower suspension arm
• Front stabilizer bar
• Rear coil spring
• Rear shock absorber
• Rear axle beam
• Tire and wheel

U340E automatic transaxle

• Speed sensor
• Transmission revolution sensor
• Park / neutral position switch
• Transmission wire
• Valve body
• Shift lock system
• Transmission control cable
• Floor shift
• Differential oil seal
• Torque converter clutch and drive plate
• Automatic transaxle unit
• Oil pump
• Input shaft
• Second brake piston
• Intermediate shaft
• Transaxle rear cover
• Valve body
• Differential case

Electrical wiring diagram

• How to use this manual
• Troubleshooting
• Abbreviations
• Glossary of terms and symbols
• Relay locations
• Electrical wiring routing
• System circuits
• Ground point
• Power source
• Connector list
• Part number of connectors
• Overall electrical wiring diagram
• ABS
• Air conditioning
• Audio system
• Back–up light
• Charging
• Cigarette lighter
• Combination meter
• Cooling fan
• Cruise control
• Data link connector 3
• Door lock control
• Electronically controlled transmission and A/T indicator
• Engine control
• Engine immobiliser system
• EPS
• Front fog light
• Front wiper and washer
• Headlight
• Horn
• Ignition
• Illumination
• Interior light
• Key reminder
• Light reminder
• Multiplex communication system (CAN)
• Power outlet
• Power source
• Power window
• Rear window defogger
• Rear wiper and washer
• Remote control mirror
• Seat belt warning
• Shift lock
• SRS
• Starting
• Stop light
• Taillight
• Theft deterrent
• Turn signal and hazard warning light
• Wireless door lock control

Customers reviews