Toyota Supra (A80) 1997 thru 2002, repair e-manual

Content

Clutch

• Clutch release cylinder
• Clutch unit
• Clutch pedal
• Clutch master cylinder

Manual transmission

• Manual transmission unit
• Oil seal

Propeller shaft

Identification information

Vehicle lift and support locations

Differential

Air conditioning

• Drive belt
• Air conditioning unit
• Compressor and magnetic clutch
• Receiver
• Evaporator
• Heater radiator
• Expansion valve
• Water valve
• Blower motor
• Pressure switch
• Air conditioning amplifier

Body electrical

• Power source
• Headlight and taillight system
• Fog light system
• Interior light system
• Back-up light system
• Stop light system
• Wiper and washer system
• Combination meter
• Electric tension reducer system
• Defogger system
• Power window control system
• Power seat control system
• Seat heater system
• Audio system

Body mechanical

• Bumper
• Door
• Window
• Instrument panel
• Seat

Brake

• Brake pedal
• Brake fluid
• Parking brake lever
• Brake master cylinder
• Brake pad
• Brake caliper
• Parking brake
• Proportioning and by-pass valve
• Abs actuator
• Speed sensor

Collision repair information

Body panel

Body dimensions

Cooling

• Water pump
• Coolant
• Thermostat
• Radiator
• Electric cooling fan

Diagnostics

Electrical

• Relay locations
• Electrical wiring routing
• Ground point
• Power source
• Starting and ignition
• Charging
• Engine control
• Headlight
• Taillight
• Fog light
• Light auto turn off
• Turn signal and hazard warning light
• Stop light
• Back-up light
• Interior light
• Illumination
• Wiper and washer
• Theft deterrent and door lock control
• Power window
• Electronically controlled transmission
• ABS
• Traction control
• Cruise control
• Shift lock
• Cigarette lighter and clock
• Remote control mirror
• Power seat
• Seat heater
• Unlock and seat belt warning
• SRS
• Electric tension reducer
• Rear window defogger and mirror heater
• Auto antenna
• Radio and player
• Combination meter
• Radiator fan and automatic
• Overall electrical wiring diagram

Emission control

• Parts layout and schematic drawing
• Drawing
• Evaporative emission control system
• Exhaust gas recirculation system
• Three-way catalytic converter system

Engine mechanical

• Timing belt
• Cylinder head
• Engine unit
• Cylinder block
• Exhaust system
• Compression
• Ignition timing

Maintenance

Supplemental restraint system

• Airbag
• Steering wheel pad and spiral cable
• Passenger airbag
• Airbag sensor
• Wire harness and connector

SFI system

• Fuel pump
• Fuel pressure regulator
• Injector
• Fuel pressure pulsation damper
• Fuel tank and line
• Throttle body
• Solenoid resistor
• Engine coolant temperature sensor
• Knock sensor
• Heated oxygen sensor
• Engine control module

Steering

• Power steering fluid
• Air control valve
• Steering wheel
• Power steering vane pump
• Power steering gear
• Progressive power steering

Suspension and axle

• Tire and wheel
• Wheel alignment
• Axle hub
• Shock absorber
• Suspension arm
• Stabilizer bar
• Drive shaft
• Differential carrier
• Shock absorber

Torque and service specifications

Wire harness repair

Customers reviews