Toyota RAV4 1994 thru 2000, repair e-manual (in Russian)
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
(9)
9
10
1
Publisher: © "Motorist"
ISBN: 978-120-110-520-5
Number of pages: 293
Format: file PDF
About the manual
Engine type: petrol / diesel
In the manual you will find
- Step-by-step guide to repair various components and assemblies
- Self-care and maintenance instructions
- Information on the design of the car and how to prevent failure
- Information for a trip to the service station, if self-repair is not possible
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
Publisher: © "Motorist"
ISBN: 978-120-110-520-5
Number of pages: 293
Format: file PDF
About the manual
Engine type: petrol / diesel
In the manual you will find
- Step-by-step guide to repair various components and assemblies
- Self-care and maintenance instructions
- Information on the design of the car and how to prevent failure
- Information for a trip to the service station, if self-repair is not possible
Content
Abbreviations
Conventions
Identification
Jacking points
Operation manual
- Instrumentation and controls
- Keys (models with immobilizer)
- Electric sunroof
- Additional door lock
- Folding the seats
- Seat transformation
- Transmission features
- Anti-lock braking system (ABS)
- Driving tips for different conditions
- Car towing
- Starting the engine
- Engine malfunctions while driving
- Wheel replacement
- Catalytic converter and exhaust system
- Car maintenance
Engine - mechanical
- Coolant check
- Checking engine oil
- Battery test
- Checking and cleaning the air filter
- Checking high voltage wires and spark plugs
- Checking the alternator drive belt
- Checking and adjusting the valve clearance
- Checking and adjusting the ignition timing
- Checking the idle speed
- Checking CO / CH at idle (models with a catalytic converter)
- Checking and adjusting the CO concentration at idle (models without a catalytic converter)
- Compression pressure test
- Timing Belt
- Cylinder head
- Removing the cylinder head
- Dismantling the cylinder head
- Checking, cleaning and repairing cylinder head parts
- Cylinder head assembly
- Installing the cylinder head
- Cylinder block
- Pre-disassembly operations
- Dismantling the cylinder block
- Checking the cylinder block
- Dismantling the piston-connecting rod assembly
- Checking the condition of the piston and connecting rod
- Cylinder boring
- Checking and repairing the crankshaft
- Replacing the crankshaft oil seals
- Piston-connecting rod assembly
- Cylinder block assembly
- Final assembly
Cooling system
- Checking and replacing the coolant
- Coolant pump
- Thermostat
- Radiator
- Cooling system fan
- Checking sensors and relays
- Sensor - coolant temperature switch
- Main motor relay
- Relay No. 1 of the electric fan
- Relay No. 2 of the electric fan
- Relay No. 3 electric fan
Lubrication system
- Checking engine oil level and pressure
- Oil and filter change
- Oil pump
- Oil cooler
Fuel injection system
- Description
- Fuel system
- Air supply system
- Electronic control system
- Precautions
- Maintenance precautions
- Precautions when using a mobile radio system
- Air supply system
- Electronic control system
- Fuel system
- Diagnostic system
- Diagnosing faults with a road test
- Electronic fuel injection system test procedure
- Fuel pump
- Fuel pressure regulator
- Injectors
- Throttle body
- Idle speed control valve
- Fuel injection main relay
- Fuel pump relay switch
- Exhaust gas recirculation electro-pneumatic valve
- Valve system for increasing idle speed when the air conditioner is turned on
- Coolant temperature sensor
- Intake air temperature sensor
- Manifold MAP sensor
- Variable resistor (models without catalytic converter)
- Knock sensor
- Oxygen sensor
- Electronic control unit
- Fuel cut-off system in forced idle modes
Ignition system
- Description of the ignition system
- Warnings
- Vehicle checks
- Spark test
- Checking high voltage wires and spark plugs
- Examination of distributor
- Switch test
- Dispenser
- Ignition coils (models with electronic ignition system without distributor)
Launch system
- How it works
- Starter
- Starter relay
Charging system
- How it works
- Precautions
- Vehicle checks
- Generator
Clutch
- Clutch pedal
- Checking the pedal height
- Checking and adjusting the clutch pedal travel
- Clutch master cylinder
- Clutch slave cylinder
- Clutch
Manual gearbox and transfer case
- Removing the manual transmission and transfer case
- Disassembly of the gearbox
- Checking transmission parts
- Gearbox input shaft
- Gearbox output shaft
- Gearbox oil pump
- Shaft of the gear selector
- Differentials
- Center differential locking system
- Oil cooler
- Disassembling the transfer case
- Transfer case driven gear bearing holder
- Transfer case final drive pinion
- Transfer case assembly
- Gear Lever
Automatic transmission
- Driving with automatic transmission
- General information
- Preliminary checks
- Checking the transmission fluid
- Checking the transfer case oil
- Changing the transmission fluid
- Changing the oil in the transfer case
- Checking and adjusting the control cable
- Automatic transmission control rod adjustment
- Checking and adjusting the engine start inhibit switch
- Idle speed check (N range)
- Gearbox diagnostics
- Self-diagnosis system
- Checking mechanical gearbox systems
- Filter replacement
- Engine start inhibit switch
- Throttle valve control cable
- Replacing the speed sensor (models with a speedometer drive)
- Replacing the gearbox front output shaft speed sensor
- Replacing the output shaft seals (front wheel drive)
- Replacing the output shaft seal (rear wheel drive)
- Gearbox assembly
Cardan shaft
Suspension
- General check
- Front wheel alignment
- Rear wheel alignment
- Front axle hub
- Front drive shaft
- Front suspension strut
- Front suspension lower arm
- Lower ball joint
- Anti-roll bar
- Rear wheel hub
- Rear drive shaft
- Differential
- Rear shock absorber
- Rear suspension arm and spring
Braking system
- Checks and adjustments
- Checking and adjusting the brake pedal position
- Checking the operation of the vacuum brake booster
- Bleeding the brake system
- Checking and adjusting the parking brake
- Brake master cylinder
- Vacuum brake booster
- Front disc brakes
- Rear drum brakes
- Pressure regulator
- Anti-lock braking system (ABS)
- Self-diagnosis system description
- Self-diagnosis system check
- Resetting trouble codes
- Troubleshooting
- Speed sensor and deceleration sensor diagnostics
- Checking the operation of the deceleration sensor
- Removing and installing pressure modulator
- Checking the pressure modulator
- Control relay test
- Checking the front wheel speed sensors
- Removing the front wheel speed sensor
- Checking the rear wheel speed sensors
- Removing the rear wheel speed sensor
- Checking the anti-lock brake system circuit (models up to 1997)
- Checking the anti-lock braking system circuit (models from 1997)
Steering
- Car check
- Checking the steering wheel play
- Checking the power steering pump drive belt
- Checking the idle speed increase system
- Checking the power steering fluid level
- Replacing the hydraulic fluid
- Bleeding the power steering system
- Checking the pressure of the working fluid
- Checking the effort on the steering wheel
- Removing the steering column
- Steering column (option without tilt adjustment)
- Checking steering column parts
- Steering column (tilt-adjustable version)
- Installing the steering column
- Power steering pump
- Steering gear
Body
- Precautions during work
- Bonnet adjustment
- Bumpers
- Front door
- Back door
- Tail door
- Windshield
- Rear side window glass (3-door models)
- Rear side window glass (5-door models)
- Tailgate glass
- Washers and wipers
- Dashboard
Air conditioning, heating and ventilation
- Air conditioning system
- Air conditioning piping
- Compressor
- Receiver
- Capacitor
- Cooling unit
- Heater block
- Heater fan block
- Expansion valve
- Electro-pneumatic valve system for increasing idle speed
- Condenser fan
- Heater fan
- Heater blower resistor
- Thermistor
- Speed sensor
- Pressure switch
- Repeat
- Air conditioner amplifier
- Air conditioner control panel
Body electrical equipment
- General information
- Precautions
- Conducting inspections
- Replacing fuses
- Connector identification
- Switching circuit breaker (thermal fuse)
- Location of relays and fuses (except for modifications)
- Location of fuses (modifications)
- Ignition lock and forgotten key warning system
- Headlight and taillight system
- Rear fog lamp system
- Direction indicator and hazard warning system
- Indoor lighting system
- Reversing light system
- Brake light system
- Headlight washer system
- Wiper and Washer System
- Instrument cluster
- Tailgate glass heater system
- Electric windows
- Central locking
- Seat heaters
- Exterior mirror adjustment system
- Electric sunroof
- Airbag and seat belt pretensioner (SRS) system
- Location of relay blocks and junction boxes
- Component and connector locations
Wiring diagrams
- Explanations for the electrical circuits
- Power system
- Launch system
- Charging system
- Cigarette lighter and clock
- Ignition system
- Engine management (models with automatic transmission)
- Engine management (models with manual transmission)
- Electronic control system of automatic transmission
- Headlights (with daytime running lights)
- Key left in ignition warning system
- Headlights (without daytime running lights)
- Headlamp leveling (headlight range control)
- Dimensions and lighting
- Interior lighting system
- Lighting warning buzzer
- Direction indicators and hazard warning lights
- Rear fog lamp
- Center differential locking system (models with manual transmission)
- Reversing lights
- Stop signals
- Headlight cleaner (LHD for Europe)
- Tailgate glass heater
- Tailgate lock control
- Electric drive mirrors
- Seat heater (LHD, Europe)
- Central locking
- Power windows
- Anti-lock braking system (ABS)
- Windscreen wiper and washer
- Sound signal
- Radio
- Instrument cluster
- Cooling fan and air conditioner condenser fan
- Air conditioning system (Europe)
- Air conditioning system (except Europe)
- Wiring Diagrams - Supplement for Models from 1995
- Power system
- Engine management (models with automatic transmission)
- Immobilizer (models with automatic transmission)
- Engine management (models with manual transmission)
- Immobilizer (models with manual transmission)
- Dimensions and lighting
- Central locking (left hand drive)
- Central locking (right hand drive)
- Power windows (left hand drive)
- Power windows (right hand drive)
- Electric sunroof
- Instrument cluster
Customers reviews
from Рома on 10/08/2021
З покупкою автомобіля вирішив відразу придбати на цьому сайті керівництво по експлуатації. Це найкраще рішення. Тепер я знаю від яких помилок слід остерігатися під час поїздок. Є деякі незрозумілі моменти, гадаю що розберусь. Дякую.
