Toyota Camry 1994 thru 2000, repair e-manual

Content

Introduction

• How to use this manual
• Identification information
• General repair instructions
• For vehicles with data link connector
• Precaution
• How to troubleshoot ECU controlled systems
• Vehicle lift and support locations
• Abbreviations used in this manual
• Glossary of SAE and toyota terms
• Standard bolt torque specifications

Maintenance

Engine

• Engine mechanical
• Timing belt
• Cylinder head
• Cylinder block
• Exhaust system
• Emission control systems
• Positive crankcase ventilation system
• Evaporative emission control system
• Exhaust gas recirculation system
• Three–way catalytic converter system

MFI/SFI system

• Fuel pump
• Fuel pressure regulator
• Injector
• FUEL Tank and line
• Throttle body
• Idle air control valve
• EFI main relay
• Circuit opening relay
• Engine coolant temperature sensor
• Intake air temperature sensor
• EGR gas temperature sensor
• Oxygen sensor
• Engine control module

Cooling system

• Coolant check and replacement
• Water pump
• Thermostat
• Radiator
• Electric cooling fan

Lubrication system

• Oil pressure check
• Oil and filter replacement
• Oil pump
• Oil cooler

Engine troubleshooting

Engine operating condition

Clutch

• Clutch system bleeding
• Clutch pedal
• Clutch master cylinder
• Clutch release cylinder
• Clutch unit

Manual transaxle

• Description
• Operation
• Preparation
• Troubleshooting
• Precaution
• Assembly removal and installation
• Component parts removal
• Input shaft
• Output shaft
• Shift and select lever shaft
• Differential case
• Shift lever and control cable

Automatic transaxle

• Description
• Operation
• Preparation
• On–vehicle repair
• Assembly removal and installation
• Shift lock system
• Troubleshooting

Steering

• Steering column
• Power steering

Suspension and axle

• Wheel alignment
• Front axle
• Front drive shaft
• Front suspension
• Rear axle
• Rear suspension

Body

• Bumper
• Hood
• Door
• Luggage compartment
• Wiper and washer
• Moulding
• Window
• Instrument panel
• Seat
• Seat belt

Body electrical

• Power source
• Ignition switch
• Key unlock warning system
• Headlight and taillight system
• Turn signal and hazard warning system
• Light system
• Wiper and washer system
• Combination meter
• Defogger system
• Power window control system
• Power door lock control system
• Sliding roof system
• Power mirror control system
• Power seat control system
• Audio system
• Clock

Brake

• Master cylinder
• Brake booster
• Front brake
• Rear brake
• Parking brake
• Proportioning valve
• Anti–lock brake system
• Brake booster
• Load sensing proportioning valve

Charging

• Description
• System circuit
• Operation
• Preparation
• On–vehicle inspection
• Generator

Ignition system

• Description
• System circuit
• Operation
• Preparation
• On–vehicle inspection
• Distributor

Starting system

• Description
• System circuit
• Operation
• Preparation
• On–vehicle inspection
• Starter
• Starter relay

Air conditioning system

• Refrigerant volume
• Drive belt tension
• Idle–up speed
• Refrigerant lines
• Air conditioning unit
• Blower unit
• Compressor
• Receiver
• Condenser
• Evaporator
• Heater radiator
• Water valve
• Expansion valve
• Air switching valve
• Blower motor
• Condenser fan motor
• Air inlet servomotor
• Air outlet servomotor
• Blower resistor
• Pressure switch
• Evaporator temperature sensor
• Revolution detecting
• Relay
• Air conditioning amplifier
• Air conditioning control assembly

Supplemental restraint

• Steering wheel pad and spiral cable
• Front passenger airbag assembly
• Front airbag sensor
• Center airbag sensor
• Wire harness and connector

Customers reviews