Isuzu KB P190 2007 thru 2011, repair e-manual
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
(8)
8
10
1
Publisher: © "Motorist"
ISBN: 977-129-542-372-0
Number of pages: 6022
Format: file PDF
About the manual
Engine type: 4JH1 / 4JJ1 / 4JA1
Engine capacity: 2.5D / 3.0D l.
In the manual you will find
- Step-by-step guide to repair various components and assemblies
- Self-care and maintenance instructions
- Car design and prevention information
- Information for a trip to the service station, if self-repair is not possible
Only original manuals
Available immediately after payment
Full compliance with the paper edition
100% protection of your payments
Publisher: © "Motorist"
ISBN: 977-129-542-372-0
Number of pages: 6022
Format: file PDF
About the manual
Engine type: 4JH1 / 4JJ1 / 4JA1
Engine capacity: 2.5D / 3.0D l.
In the manual you will find
- Step-by-step guide to repair various components and assemblies
- Self-care and maintenance instructions
- Car design and prevention information
- Information for a trip to the service station, if self-repair is not possible
Content
General information
- General repair instructions
- Notes on the format of this manual
- Identification
- Lifting instructions
- Conversion table
Maintenance and lubrication
- Maintenance schedule
- Severe conditions maintenance schedule
- Recommended fluids and lubricants
- Oil viscosity chart
Heating and ventilation
- General description
- Main data and specifications
- Special parts fixing nuts and bolts
- On-vehicle service
- Condenser
- Condenser fan motor
- Receiver / drier
- Compressor
- Heater unit
- Vent unit
- Evaporator
- Duct
- Blower unit
- Defroster nozzle and vent duct
- Rear heater duct
- Control lever
- Control panel illumination bulb
- Troubleshooting
- Special service tool
Frame and bumper
- Front bumper
- Rear step bumper
- Rear bumper and rear guard
- Front air dam
- Frame dimensions
- Sheet metal
- Front alignment
Power assited steering system
- General description
- Power steering system test
- Maintenance
- Fluid level
- Bleeding the power steering system
- Bleeding procedure
- Flushing the power steering system
- Steering wheel free play inspection
- Front end alignment inspection and adjustment
- Special tools
- Power steering unit
- Power steering pump
- Supplemental restraint system steering wheel and column
- Inflator module
- Steering wheel
- The adjustment method in case a mark has not been applied
- Combination switch
- Lock cylinder
- Steering column
- Supplemental restraint system steering wheel and column and associated parts
Front suspension
- Main data and specifications
- Torque specififcations
- Front suspension
Rear suspension
- Main data and specifications
- Rear suspension
- Leaf spring and shock absorber
- Leaf spring assembly
- Rear stabilizer bar
- Troubleshooting
Wheels and tires
- Main data and specifications
- Torque specifications
- Wheels and tires
- Troubleshooting
Propeller shaft
- Service precaution
- Main data and specifications
- Rear propeller shaft
- Front propeller shaft
Rear axle
- Main data and specifications
- Recommended liquid gasket
- Recommended thread locking agents
- Rear axle assembly Servicing
- Rear axle
- Differential
- Differential cage
- Limited slip differential
Front wheel drive
- Main data and specifications
- Special parts fixing nuts and bolts
- Recommended liquid gasket
- Recommended thread locking agents
- Servicing
- General description
- Front drive axle
- Front axle drive shaft
- Differential
- Front hub and disc
- Troubleshooting
- Special service tool
Shift on the fly system
Brake control system
- Service precaution
- General description
- General diagnosis
Anti-lock brake system
- Service precaution
- Torque specifications
- Electronic hydraulic control unit
- Front wheel speed sensor
- Rear wheel speed sensor
- Front sensor rotor
- Rear sensor rotor
- G-sensor
- Special tools
Brakes
- General description
- Main data and specifications
- Torque specifications
- Servicing
- Front disc brake
- Rear drum brake
- Brake control
- Master cylinder
- Vacuum booster
- Special tools
Parking brake system
- Service precaution
- Parking brake lever
- Front parking brake cable
- Parking brake lever
- Parking brake rear cable
- Main data and specifications
Engine mechanical
- Main data and specifications
- Torque specifications
- Recommended liquid gasket
- Loctite application procedure
- Servicing
- General description
- Removal and installation
- Engine repair kit
- Engine overhaul
- Inspection and repair
- Reassembly
- Installation
- Lubrication system
- Lubricating flow
- Oil pump and oil filter
- Oil pump
- Oil filter and oil cooler
- Inter cooler
- Special tools
Engine cooling
- Main data and specifications
- Diagnosis
- Draining and refilling cooling system
- Water pump
- Thermostat
- Radiator
- Fan clutch with cooling fan
Fuel system
- Main data and specifications
- General description
- Fuel tank
- Fuel gauge unit
- Fuel tube / quick - connector fittings
- Filler neck
- Fuel filler cap
- Injection pump
- Injection nozzle
- Special tools
Engine electrical
- Main data and specifications
- General description
- Torque specifications
- Generator
- Starter motor
- Pre-heating system
Engine control system
Exhaust system
- Main data and specifications
- General description
- Removal and installation
- Inspection and repair
- General description
- Egr system diagram.
- Egr cooler
- Turbocharger
- Special tools
- Ihi service network
Accelerator control
Ignition system
- General description
- Service precaution
- Diagnosis
- Ignition coil
- Spark plug
- Crankshaft angle sensor
- Main data and specifications
Starting and charging system
- Starting system
- General description
- Service precaution
- Diagnosis
- Starter
- Charging system
- Generator
- Technical data
Engine driveability and emissions
Induction
- Service precaution
- Air cleaner filter
Transmission
- Automatic transmission 4l60E
- Transmission AW30-40LE model
- Transmission JR405E model
- Manual transmission msg mua mux models
- Clutch
- Transfer case
Electrical-body and chassis
- General information
- Notes for working on electrical items
- Symbols and abbreviations
- Parts for electrical circuit
- Wiring
- Fuse
- Fusible link
- Relay
- Diode
- Connector
- Battery
- Reading the circuit diagram
- Parts location
- Circuit diagram
- Connector list
- Main data and specifications
- Bulb specifications
- Relay and fuse
- Relay and fuse box location
- Relay location
- Fuse and slow blow fuse location
- Diode location
- Fuse block circuit
- Grounding point
- Cable harness routing
- System repair
- Connector list
Cruise control system
- General description
- Brake switch
- Clutch switch
- Starter switch
- Cruise control main switch
Accessories
- Parts location
- Circuit diagram
- Connector list
- Audio
- Front speaker
- Tweeter
- Rear speaker
- Clock
- Antenna
Supplemental restraint system
- Service precaution
- General description
- Circuit diagram
- SRS component and wiring location view
- Component description
- Definitions
- Diagnosis
- SRS connector body face views
- Repairs and inspections required after an accident
- On-vehicle service
- Air bag assembly handling / shipping / scrapping
- Air bag assembly shipping procedure for live (undeployed) air bag
- Service precautions for SRS component service
- SRS connectors
- SRS control unit
- Driver air bag assembly
- Steering wheel
- SRS coil assembly
- Steering column
- Passenger air bag
- Pretensioner seat belt
- Main data and specifications
- Special tools
Restraint control system
- Service precaution
- Diagnosis information
- Diagnostic procedures
- Diagnostic codes
- How to read trouble codes
- How to clear trouble codes
- Scan tool diagnostics
- Basic knowledge required
- Basic electrical circuits
- "Flash code" diagnostics
- Data list
- Diagnostic trouble codes
- System schematic
- SRS diagnostic system check
Cab
- Windshield
- Rear window
- Front door
- Rear door
- Instrument panel
- Floor console
- Console box
- Headlining
- Interior trim panels
- Fuel filler lid opener lever / cable
- Quarter glass
- Front seat
- Rear seat
- Jump seat
- Front seat belt
- Rear seat belt
- Front wheel extension
- Rear wheel extension
- Tail gate
Security
- Immobilizer control system
- Immobilizer system
- Antitheft system
Customers reviews
from Gareth on 02/01/2025
Lots of useful information, clear diagrams, accessible step-by-step instructions. I replaced the brake discs and checked the suspension system myself
